Dane Technologies, Inc.
QuicKART 2000
Owner’s Manual
7105 Northland Terrace, Minneapolis, MN 55428 / 888-544-7779 / 763-544-7779 / Fax 763-544-4234
www.danetechnologies.com
970-026 rev 3-1-06
35
OPERATION OF THE Q
UIC
KART 2000
MANUAL MODE:
To operate the QuicKART 2000 in the Manual Mode, perform the following steps:
1)
Insert the key into the key-switch located on the control panel. Turn the key
clockwise to turn the QuicKART "on".
2)
Lights on the control panel will show the system status (see illustration on page
34). Confirm that all systems are working properly.
3)
In manual operation, while standing behind the machine, both hands on the
handles, slowly twist the throttle control and the QuicKART will start to move
forward. Slowly release the pressure on the throttle control and the QuicKART will
slow to a stop. When the throttle control is fully released, the electronic brakes will
be applied. When moving forward or backward, a sudden release of the throttle
control will cause the automatic brake to bring the QuicKART to a sudden halt.
4)
To change the direction of travel, the QuicKART must be stopped. Press the
direction switch on the control panel and the light for the selected direction will be
displayed.
5)
To turn the power off (emergency only), press the emergency shut off button or
turn the key counter-clockwise.
Note: Do not leave the machine "ON" and do
not leave the key in the switch when unattended.
6)
The collection of grocery carts begins by walking the QuicKART into the parking lot
to a location where customers have left carts. To attach the first cart, open the
locking U-pin on the left side of the cart coupler assembly. Position the rear of the
first shopping cart so that its vertical rear frame is aligned with the yoke openings
on the coupler assembly. Lift the cart slightly off the ground and move it sideways
until it engages both coupler yokes. Then, put the locking U-pin back into place to
secure the shopping cart. It is recommended that the first cart be left permanently
in place or if removed at night, identified, so the same cart is always attached to
the cart. The coupler yokes can be adjusted up and down and from side to side to
accommodate various types and sizes of grocery carts. See illustration on page 23
and 24.
7)
Additional shopping carts can now be collected to form a train of a maximum of 20
carts.
To Order Parts Call 1-888-702-5326 - https://monsterfloorequipmentparts.com
