DT-50 and DT-50A Tire Changer
41
P/N 5900260 — Rev. A1 — Dec. 2020
Secure the Wheel on the Turntable
Before you can demount a Tire, you must secure the Wheel on the Turntable.
The Tire Changer supports two methods of securing a Wheel:
•
External clamping
. The Clamps are on the outside of the Wheel’s Rim, pressing inwards.
•
Internal clamping
. The Clamps are on the inside of the Wheel’s Rim, pressing outwards.
As a general rule, steel Wheels clamp internally and custom and mag Wheels clamp externally. Check
with your supervisor if you are unclear about which method to use for a particular Wheel.
To secure a Wheel on the Turntable
:
Make sure you are wearing OSHA-approved (publication 3151) Personal Protective Equipment:
leather gloves, steel-toed work boots, back belts, hearing protection, and ANSI-approved eye
protection (safety glasses, face shield, or goggles).
Identify the Narrow side of the Tire; this side goes up.
Determine which clamping method you are going to use.
–
If you are clamping externally, move the Clamps all the way
out
.
–
If you are clamping internally, move the Clamps all the way
in
.
Put the Wheel onto the Turntable, either between the Clamps that are all the way out for external
clamping or over the Clamps that are all the way in for internal clamping.
Secure the Wheel:
–
If you are clamping externally, move the Clamps
in
until the Wheel is being held firmly in place.
–
If you are clamping internally, move the Clamps
out
until the Wheel is being held in place.
Tip
This tip applies to the DT-50A only. Clamping externally can be difficult with some hard
sidewall Tires. If you are having problems getting the Clamps to hold externally, press
down on the Wheel using the Restraint Block and the Assist Arm on the Wheel from
above. See
Summary of Contents for DT-50
