Raider-Classic 150 (Oil-cooled&Internal Gearbox): Service Manual (single/ double-seat) EEC Version;3.0 Feb..2005
9
2. Periodic Maintenance and Tune –up Procedures
2.1 Periodical Checks and Services
The maintenance intervals in the following table are based upon average riding conditions.
Riding in unusually dusty areas requires more frequent services.
Time of Service
Items
Initial Service
(First Week)
Monthly Quarterly Yearly
Tire Pressure/Wear
I I
Brake Performance
I I
Bolt Tightness
I I
Air Cleaner
C
C
I
Carburetor
I A
C
Spark Plug
C,
A
Drive Chain
I I
C,
A,
L
Brake Fluid
I
Replacement Of Gearbox Oil
I
R
Chassis
C,
I
L
Fuel Switch/Fuel Tank
C
Chassis I
I
Engine Oil
R
Valve Clearance Of Engine
A
Notes
: A: Adjust; C: clean; I: inspect, clean or replace if necessary; L: lubricate; R: replace.
2.2
Maintenance and Tune-up Procedures
This section describes the servicing procedures of every item in the Periodic Maintenance Intervals
Table above.
2.2.1 Spark Plug
Clear up the carbon around the spark plug to prevent it from dripping into the cylinder when
removing the spark plug.
Remove the spark plug:
a) In general, it should be carried on after the engine has cooled down;
b) If the spark plug is too tight to remove, spray some rust inhibiter on
The spark plug washer and the thread part; after the inhibiter has
soaked the washer and thread part, rotate the spark plug;
c) Clear up the filth and carbon accumulation on the spark plug with a
steel brush or a blade;
Summary of Contents for Raider-Classic 150
Page 1: ......
