3. Maintenance and Troubleshooting
H-110-200E V00
Page 12
(Continued)
Symptom
Cause and correction
Noisiness
The pump sucks air. One or more valve springs are broken or
down. Extraneous matter in the valves. Crankcase or motor
bearings worn out.
Inspect the low-pressure supply. Replace springs. Clean the
valves. Replace the bearings.
Water in the oil
The O-ring casing is worn out. High moisture in the air
(condensing inside the crankcase) The seals are completely worn
out.
Check or replace the O-ring.
Renewal of the crankcase oil more often.
Replace the seals.
The boiler will not
burn
The fuel tank is empty. The fuel filter is clogged. The fuel nozzle is
clogged. The spark electrodes are worn or out of alignment. The
flame censor device is active. The glass between the flame censor
and the boiler is dirty.
Fill up the fuel-tank. Clean or replace the fuel filter. Clean or
replace the fuel nozzle. Adjust or replace the spark electrodes.
Reset the device by pushing the reset button at the control panel.
Clean the glass between the censor and boiler.
When using chemical
injector
The high-pressure
cleaner does not suck
chemicals
The chemical container is empty. The high-pressure cleaner has
not been set to low-pressure (on the double barrel lance cock).
The low-pressure nozzle is clogged, or partly clogged. The non-
return valve of the chemical injector is stuck.
Ensure the chemical container contains sufficient fluid for proper
suction.
Set the spray-lance to low pressure by turning the cock on the
lance counter-clockwise.
Clean or replace the low-pressure nozzle.
Clean, correct or replace the non-return valve of the chemical
injector.
For any further inconveniences, not mentioned in this user guide or any
damages of the machine, we strongly suggest you to make contact with your
dealer for the repair or possible replacement of any original spare-parts.
NOTE
Summary of Contents for H-110-200E
Page 20: ...4 Spare Part List H 110 200E V00 Page 19 Boiler assembly H 110 200E ...
Page 23: ...4 Spare Part List H 110 200E V00 Page 22 Pump assembly H 110E ...
Page 26: ...4 Spare Part List H 110 200E V00 Page 25 Pump assembly H 200E ...
Page 34: ...4 Spare Part List H 110 200E V00 Page 33 H 200E 220V 60Hz Standard ...
