background image

PREVENTIVE MAINTENANCE 

1. Daily lubrication and cleaning is necessary to maintain the best condition of the gun.
2. To clean the gun body, wipe exterior with solvent dampened cloth.    Do not submerge the gun body in solvent as any

solids may get into the air passage and cause troubles.

3. Do not leave the gun with solvent in fluid cup.    Clean the spray gun after used with clean solvent and empty the cup.

To clean the fluid cup, after removing extra paint, through the appropriate solvent and flush down the residual paint.

4. The Air Cap can be immersed in solvent and brushed down for cleaning.    If orifices are clogged, use a toothpick to

remove obstruction.  Never use a steel wire or hard instrument.  This will damage air cap and result in a distorted
spray pattern.

5. Do not immerse any plastic parts in solvent for long time.
6. Certain portions of gun should be lubricated.   Do not lubricate to any portion where not instructed.   For lubrication,

SSL-10 Gun Lube* is recommended (*sold separately, vegetable not repelling materials).

7. The following portions should be lubricated regularly; Trigger Bearing Stud (20), Pattern Valve (9), threads of cheater

Valve (22) and Adjusting Screw (16), Air Valve (11) stem, portion of Packing Gland (18) where Needle (14) comes in and
out.

8. When installing Air Cap (3), make sure no foreign materials adhered on Retaining Ring (1) and thread of Baffle (5) and

then oil one drop of Gun Lube SSL-10.

9. Apply non-silicone grease lightly on Needle Spring (15) and Air Valve Spring (12).    Do not apply too much grease as it

may clog the air passage.

REPLACEMENT OF PARTS 

Before replacing gun parts, remove materials from the gun for cleaning.    Then release the air pressure in the gun and 
disconnect air hoses.    All repairs should be made on a clean flat surface.    Use only appropriate tools indicated for 
replacement of parts. 

Fluid Tip 

4

  and Needle 

14

 

1. It is recommended to replace Fluid Tip 

4

  and Needle 

14

  as a set.

2. Loosen completely Pattern Valve 

9

  by turning the knob counterclockwise.

3. Remove Adjusting Screw 

16

  and Needle Spring 

15

  and then withdraw Needle 

14

  from the gun body.

4. Remove Retaining Ring 

1

  and Air Cap 

3

.

5. Remove Fluid Tip 

4

  by using socket wrench or offset wrench and Baffle 

5

  can also be removed.

6. When reassembling, it is recommended to replace Gasket 

6

  which is consumable.

7. Recommended torque of Fluid tip (4) is 15

N・

m.

Fluid Nipple 

7

  and Air Connector 

23

 

Fluid Nipple 

7

  and Air Connector 

23

  are fixed together with fluid packing.    Use offset wrench for disassembling and 

reassembling.    When reassembling, apply fluid packing to threads of gun body. 

Pattern Valve 

9

  and Cheater Valve 

22

 

When disassembling and reassembling Pattern Valve 

9

  and Cheater Valve 

22

, turn the knobs completely 

counterclockwise and then disassemble or reassemble them. 

Valve Seal Kit 

10

, Air Valve 

11

, Valve Spring 

12

  and Air Valve Bushing 

13

 

Valve Seal Inserting Tool 

24

  is required for replacing Valve Seal Kit 

10

.    When replacing Valve Seal Kit 

10

be careful  not to damage the surface of seals of Gun Body 

8

, Air Valve Bushing (13) and Air Valve 

11

  to 

prevent air leakage. 

1. Remove Needle Adjust Screw 

16

  and Needle Spring 

15

  and then withdraw Needle 

14

  from the Gun Body (8).

2. Remove Air Valve Bushing 

13

  by using 17

mm

  offset wrench.

3. Withdraw Valve Spring 

12

  and Air Valve 

11

  from the gun body.

4. Withdraw Valve Seal Kit 

10

, being careful not to damage where fitted to.

5. Insert each seat by using Valve Seal Inserting Tool. 

24

.

6. Insert Air Valve 

11

  to the bottom end, being careful not to damage the seat, and then insert Air Valve Spring 

12

.

7. Install Air Valve Bushing 

13

  by using offset wrench.

Needle Packing 

17

 

1. Install Needle Packing 

17

  in the direction shown per drawing.

2. Adjust Needle Packing (17).    Tighten the Packing Gland (18) gradually and then to adjust the needle moving smoothly,

untighten a little where the Needle (14) is not well pulled back.

Summary of Contents for LUNA-R

Page 1: ... LUNA 3 244 G 220L min 0 2MPa 260 Metallics Pearls G1 4 G1 4 245 S 245 LUNA 3 245 G 220L min 0 2MPa 300 Clear Coats Solids S PARTS LIST Chart 2 Ref Part Number Description Qty 1 JJ 6 Retaining Ring 1 2 JJ 50 K5 Seat Kit of 5 1 3 See Chart 1 Air Cap 1 4 See Chart 3 Fluid Tip 1 5 LUNA 7C Baffle 1 6 LUNA 8 K5 Gasket Kit of 5 1 7 LUNA 35 Fluid Inlet 1 8 LUNA BODY G LUNA BODY S Gun Body 1 9 LUNA 44C Pa...

Page 2: ...essured liquids may injure eyes Do not point the spray gun to any person 3 Gravity or suction feed gun must not be used for pressure feed gun 4 Parts with compressed air may damage the human body Connect air hoses tightly by using a spanner so that air never leaks If tightened loosely hoses can be removed which may result in damaging the human body objects to be coated and other equipment used tog...

Page 3: ... Tip 4 and Needle 14 1 It is recommended to replace Fluid Tip 4 and Needle 14 as a set 2 Loosen completely Pattern Valve 9 by turning the knob counterclockwise 3 Remove Adjusting Screw 16 and Needle Spring 15 and then withdraw Needle 14 from the gun body 4 Remove Retaining Ring 1 and Air Cap 3 5 Remove Fluid Tip 4 by using socket wrench or offset wrench and Baffle 5 can also be removed 6 When reas...

Page 4: ... Replace Dripping from fluid tip 1 Worn or damaged Fluid Tip 4 or Needle 14 2 Stuck Needle Packing 17 or Needle 14 3 Tight Packing Gland 18 4 Loose Adjusting Screw 16 1 Replace 2 Lubricate 3 Adjust 4 Tighten ACCESSORIES Part Description Part Description KGP 4 Plastic Gravity Cup with Stand 400ml HAV 501 B Air Adjusting Valve with Gauge KG 250 Stainless Steel Gravity Cup with Stand 250ml HAF 507 Di...

Reviews: