User manual in Original
Doc. ref: 500A_GTS-E65_am_en_210608
DISPERATOR AB
Tel: 08-724 0160
E-mail: info@disperator.se
Mälarvägen 9, 141 71 Segeltorp
Web page: www.disperator.se
10 / 48
3. Product Description and Technical Specification
3.1. Food Waste Processor 500A-GTS-E65 EXCELLENT-Series for Free-standing
Installation
Immediately and efficiently removing the heaviest part of kitchen waste – i.e. food leftovers - is a
necessity in any commercial kitchen. In the event water-based food waste disposers connected to the
municipal sewer system is not permitted in your community, a by Disperator developed unique and
patent pending technology can handle the task for you. When using a GTS-Series processor, food waste
can hygienically and without any heavy lifting or manual transfer easily take care of and reduce the total
amount of refuse – by volume, but especially in the handling of the total weight in different transport
phases!
Regardless of the selected model, the disposal procedure is the same. Food waste is fed down the inlet
hopper of the machine and ground into small particles in a disposer for further transport in a pipe using
a processor pump to a sealed and odorless tank. The tank is emptied by a vacuum truck approximately
every four weeks or according to the driving schedule that applies in your municipality. Depending upon
preference, the tank may be placed outdoors buried in the ground, as well as placed indoors. One of the
unique benefits of this processor technology is that the pumping of the ground food waste can be done
with minimal amount of flushing water, which gives a good operating economy as the tank does not
need to be emptied as often. The slurry is transported to an anaerobic digestion facility and converted
into valuable renewable energy resource (i.e. biogas), and often the digested residue can also be used
as fertilizer on farmland. Biogas is one of our society’s most environmentally clean and desired energy
forms, as fuel for vehicles as well as to produce heat and electricity.
In its standard version the GTS-processor has a capacity of up to 15 l/min. With an average amount of
food waste of 0.15 l/served meal, the processor can take care of food waste generated by as many as
4,000 served guests/hour. And this even though the storage tank, if required, can be located over 100
meters away.
To suit existing interior and logistics within the kitchen, the E65-processor outlet may be positioned
either to the left or to the right of infeed opening, thus giving full flexibility in planning your kitchen and
possibility to fully utilize valuable space. Disperator’s broad assortment of different technical solutions
for source separation of food waste can be adapted to your specific kitchen and your specific working
environment, regardless of size or layout, and regardless of the specific municipal’s food waste handling
rules in your community!
Food waste disposers within the Disperator Excellent Series have the Declaration of Compliance issued
by DNV, verifying compliance with applicable sections of MARPOL consolidated edition 2017 ANNEX V for
disposal of ground food waste into the open sea.
Summary of Contents for 500A-GTS-E65 EXCELLENT SERIES
Page 2: ......
