Geelseweg, 80 | 2250 | Olen | BELGIUM | Tel. +32 (0) 14 25 92 83 | henry.dumor@hotmail.com | www.dumor.be
42
SCREEN 19 __________________________________________________________________________________________
Service mode entry screen
Input mode =checking the sensors
Output mode = electro mechanical device run testing
Adjust mode = correcting and setting the cut and slit home positions
The input values are in terms of 1/1000th movement of the print on the sheet
MECHANICAL SETTINGS
Infeed
Setting the tray upper limit knob
13
The knob is factory set to the correct position and should not need to be altered.
If the paper stops too high turn to the left.
If the paper stops too low turn to the right.
The adjustments are minute.
14
Setting the skew knob
See diagram D
The knob is set straight at the factory and should not need to be re set unless the paper is cut skewed
Basically if the paper is fed skewed to the right move the wheel so that the register plate orients to the left and vice
versa.
There is a window with a marker indicating the central position ans skew amount.
The adjustments are minute.
14
17
Setting the air blast vent knob
The air amount should be just enough to get the top sheet lifted from the pile and a clean feed.
Too much air will cause the sheets to shimmy and loose infeed accuracy leading to poor cutting.
The air vents open progressively to adapt to different sheet widths.
The adjustment is minute.
18
Setting the separator finger knob
The fingers need to be set so that only the top sheet will get by.
Clockwise
closes the gap.
The adjustment is minute.
A too tight gap will lead to late or missed sheet feeds.
Summary of Contents for Aerocard-Strike
