12
13
BARS DIAGNOSIS SOLUTION
10
Green
High Battery Voltage
Check Batteries
9
Green
Solenoid Brake Fault
Check Motor/Brake Wiring
8
Green
Possible Controller Fault
See Authorized Service Center
7
Yellow
Possible Joystick Fault
See Authorized Service Center
6
Yellow
Inhibit Active
Unplug Charger/Check
Connections
5
Yellow
Right Motor Wiring Fault Check
Right Motor Wiring
4
Yellow
Right Motor Disconnected
Check Right Motor Wiring
3
Red
Left Motor Wiring Fault
Check Left Motor Wiring
2
Red
Left Motor Disconnected
Check Left Motor Wiring
1
Red
Low Battery Voltage
Check Batteries/Battery Wiring
Freewheeling
For convenience, your LIBERTY™ 624 MINI is equipped with two freewheel levers. These levers
allow you to disengage the drive motors and maneuver the chair manually. Locate the 2 metal bars
protruding from the frame cover and turn them toward the outside of the powerchair. To reengage
the drive motors, turn the metal levers back to the forward position. If the lever is difficult to move
in either direction, press the lever downward and roll the LIBERTY™ 624 MINI forward and
backward slightly. The lever should then move to the desired position.
Eagle Note:
It is important to remember that when the LIBERTY™ 624 MINI is in the freewheel
position, the braking system is disengaged.
WARNING:
Avoid placing the LIBERTY™ 624 MINI in freewheel on an incline as the unit could
roll on its own causing injury.
Main Circuit Breaker
The circuit breaker is located under the main body cover on the left rear side of the frame.
The main circuit breaker is a safety feature built into your LIBERTY™ 624 MINI. When the
batteries and the motors are subjected to excessive loads, the main circuit breaker might trip
to prevent damage to the motors and/or electronics. If this happens, allow the unit to rest for
approximately one minute, to allow time for the automatic rest circuit breaker to reset. You may
wish to charge the batteries more frequently and have an authorized service center or service station
load test the batteries to determine how they operate under normal operation.
Eagle Note: If the main circuit breaker continues to trip, you should return to your authorized
LIBERTY™ 624 MINI dealer for service.
