Eaton 93PM Universal Integrated Battery Cabinet (IBC-LW and IBC-LHW) Installation Manual P-164000541—Rev 04
35
44..33
IInnssttaalllliinngg IIB
BC
C P
Poow
weerr W
Wiirriinngg
IBCs can be installed in a line-up-and-match configuration with the power wiring routed through the bottom of
the IBCs and UPS cabinet or in a standalone configuration with the power wiring routed between the IBCs and
the UPS cabinet using conduit. Use the appropriate procedure for the type of installation being wired.
44..33..11
LLiinnee--U
Upp--aanndd--M
Maattcchh P
Poow
weerr W
Wiirriinngg
NOTE 1
All battery cabinets will be directly connected to the UPS and not daisy-chained between
each cabinet. All power wiring between the IBCs and the UPS is factory supplied.
NOTE 2
Up to four IBCs can be installed in a line-up-and-match configuration.
NOTE 3
If installing three or four IBCs, longer battery power cables are packed with IBC 3 and
IBC 4. Ensure the longer cables are used to wire IBC 3 and IBC 4.
NOTE 4
See paragraph
, and
for wiring and
termination requirements.
NOTE 5
Refer to the applicable Eaton 93PM UPS Installation and Operation manual, listed in
paragraph
, for UPS cabinet termination requirements.
Use this procedure to wire line-up-and-match Eaton 93PM Universal Integrated Battery Cabinets to the Eaton
93PM UPS cabinet.
To install wiring to connections:
1.
Verify the UPS system is turned off and all power sources are removed. Refer to the applicable Eaton
93PM UPS Installation and Operation manual, listed in paragraph
, for UPS
operating procedures.
2.
If not already removed, remove the front door by loosening the left and right side bottom screws and
removing four top screws (see
) from the door. Lift the door to disengage the door from the
bottom screws. Retain the hardware for later use.
3.
Remove the screws securing the internal safety shield panel and remove the panel to gain access to the
battery power terminals. Retain the hardware for later use.
4.
Remove the DC power terminal shield. See
for shield location.
Summary of Contents for 93PM IBC-LW
Page 4: ......
Page 78: ...P 16400054104 P 164000541 04...
