MAINTENANCE
STORAGE
C =
Check
C A =
CheckAdjust
R =
Replace
S =
Service
C L =
CleanandLubricate
L =
Lubricate
Remarks
Pre-
Operation
20 rounds
20 hours
20 hours
160kms(
Every
Month
)
125
rounds
125 hours
600 miles
1000kms (
Every 6
250 rounds
250 hours
1200 miles
1000kms(
Every
Years)
500 rounds
500 hours
2500 miles
4000kms(
Every2
Years)
1000
rounds
1000 hours
5000 miles
8000kms
(Every 4
Page
P
re
-Ope
ra
ti
on
Charge
Clean Battery tops,for
tightness of hold-down screws
and terminals
Check brake pedal freeplay and
adjust if necessary
Check steering operation
Check tire pressure tread
depth tire surface for damage
Check bode and chassis,for damage
Check tightness of all bolts,nuts and
screw
Check reverse buzzer
E
ve
ry
mont
h
Check electrolyte level
C h e c k f o r l o o s e o r b r o k e n
connectionsw
C l e a n L u b e P e d a l
control area
Ev
e
ry
6
mo
n
th
Check all wire insulation for crack
and/or worn spots
Check shock absorbers for oil
leaks and damaged springs
E
ve
ry
ye
ar
Perform a discharge test
protectant
Check shoe lining thickness
and rear axle beating play
C h e c k s t e e r i n g k n u c k l e
bushing freeplay/Adjust wheel
alighment
Check wheel not tightness
front wheel bearing play
Check gear box oil level and
leakage
Check operation and adjust pedal
stop if necessary
E
ve
ry4mont
h
Replace gear box oil
C h e c k f o r g r e a s e
leakage;adjust gear box if
Items without a page number reference should be serviced by approved
agent or qualified technician.
This manual doesn't contain these procedures. They are contained in the
Service Manual
2 6
Perform the following preparations
when leaving your golf car unused
for a long time:
NOTE:
Turn the main switch key “OFF”,
remove the key, and put it in a safe
place.
CHASSIS PREPARATION
1.
Verify the air pressure of the
tire is 25psi ( 3 kgf/cm3);
2.
Clean the outside of the car with
anti- rust oil;
3.
Cover the car and store it in a
dry and well-ventilated place.
BATTERY PREPARATION
1.
. Recharge the batteries and
check the fluid levels at least
once a month.
2.
Disconnect cables in case of
long storage
C A U T IO N
Cleaning products are forbidden
to put into battery cells
3. Clean the top of the batteries
with baking soda and water so as
to avoid erosion.
2 7