Tug Compact—Operating Manual
11
Maintenance
Batteries
If this unit is not being used for an extended period of time, it should be connected to
the battery charger to check the battery level on a regular basis, and placed on charge
overnight if required. This will ensure the batteries are kept in good condition.
The batteries are sealed and maintenance free. DO NOT attempt to open these
batteries. If the unit is not charged as above, the batteries may be exhausted and have
dropped below the charging threshold of the battery charger. The supplied charger
cannot begin to charge the batteries unless they have a small amount of charge. If this
occurs, contact Electrodrive or your local service agent.
A sign that the batteries need replacing is when they no longer hold charge.
Tyres
The tyres should be maintained at a pressure of 40 psi. For replacement tyres, please
contact an authorised Electrodrive technician.
Motor and transmission
The transaxle is a sealed unit and does not require regular maintenance.
Brakes
The dynamic braking system does not require regular maintenance.
Motor controller
This unit is not serviceable. Any difficulties experienced with speed control should be
referred to Electrodrive.
Throttle lever
The throttle lever and cable do not require maintenance. Should the lever or cable suffer
damage they should be replaced. If the handle loosens with wear, the hinge nut can
be gently tightened. However, first confirm that the lever is in the correct position as it
may need to be reset. (Test by squeezing the lever slightly. The Tug should slowly move,
release and the Tug should completely stop).
Fuses
The control circuit is protected against inadvertent current over-loads. This fuse is
located adjacent to the controller under the top cover.
