27
r5IJTXBUFSIFBUFSJTBIJHIFGàDJFODZGVMMZDPOEFOTJOHBQQMJBODFXIJDIQSPEVDFTBDJEJDDPOEFOTBUF
during operation. The water heater incorporates a collection and removal system which must be
properly drained in order to ensure proper operation of this appliance.
r5IF Q) MFWFM PG UIF DPOEFOTBUF JT BQQSPYJNBUFMZ "O FYUFSOBM OFVUSBMJ[FS NVTU CF JOTUBMMFE PO UIF
drain piping prior to disposal when required by local code or when the condensate could cause damage.
r*GBOFYUFSOBMOFVUSBMJ[FSJTJOTUBMMFEQFSJPEJDSFQMBDFNFOUPGUIFOFVUSBMJ[JOHBHFOUXJMMCFSFRVJSFE
Refer to the instructions supplied with the neutralizer for suggested replacement intervals.
r*OPSEFSUPESBJOUIFDPOEFOTBUFBUISFBEFEàUUJOHJTQSPWJEFEBUUIFCBTFPGUIFXBUFSIFBUFS
Do not reduce the size of this fitting or the drain piping to less than 1/2".
In cold climates, do not drain the condensate to the outdoors. If the drain pipe freezes during cold
weather, the pipe will not drain condensate and the unit will stop operating.
r6TFQMBTUJDQJQFTVDIBT17$GPSUIFESBJOMJOF%POPUVTFTUFFMCMBDLJSPOPSBOZPUIFSNBUFSJBM
which can corrode when placed into contact with acidic condensate.
r,FFQUIFMFOHUIPGUIFESBJOQJQFBTTIPSUBTQPTTJCMF-POHSVOTPSBQQMJDBUJPOTXIFSFUIFOFBSFTU
drain is above the water heater will require the use of a condensate pump. Size the pump to allow for
a maximum condensate discharge of 2 GPH from the water heater.
r)PSJ[POUBMSVOTNVTUCFTMPQFEQFSGPPUUPXBSETUIFESBJOPSDPOEFOTBUFQVNQ5IFDPOEFO
-
sate will be discharged by gravity force only. Make the drain pipe run as short as possible.
r5IFFOEPGUIFESBJOQJQFNVTUOPUCFTVCNFSHFEJOXBUFSPSCMPDLFEJOBOZXBZ5PFOTVSFQSPQFS
drainage, leave the end of the drain pipe open to the atmosphere. Do not have a trap. Also, make
sure that there are no obstructions blocking the drain line from discharging condensate.
r#FTVSFUPDIFDLUIBUDPOEFOTBUFJTGSFFMZáPXJOHGSPNUIFESBJOQJQJOHBGUFSUIFTZTUFNIBTCFFO
installed. Condensate will begin flowing out of the water heater within 15 minutes after operation has
started.
r5BLF NFBTVSFT UP QSFWFOU UIF DPOEFOTBUF ESBJO MJOFT GSPN GSFF[JOH JOTVMBUJPO IFBU UBQF FMFDUSJD
heaters, etc.).
11.
Condensate Piping
Drain pipe
Drain connecting
supply
Heat insulation
material
Water heater
Do not pitch the drain line up
once a horizontal section has
been introduced.Always pitch
the drain line down to ensure
proper drainage.
Drain pipe
Due to the acidic nature of the condensate, be sure to properly drain and if necessary, treat the
condensate prior to disposal. Damage caused by improperly handled condensate is not covered
by the warranty.
CAUTION
