Check the oil tank level manually during every
other refueling operation.
The unit is also equipped with an oil level
indicator lamp. The lamp will light when the oil
level in the tank is Iow. When the lamp is lit you
MUST refill the oil tank.
DO NOT
allow the engine to operate with an
empty oil tank. Doing so will result in extensive
damage to your engine. This damage is not
covered under the warranty.
Fill the tank with high quality JASO FC grade
2 cycle engine oil. Using lower grade oil can
cause exhaust smoke and result in damage to
your engine.
Your first tank of fuel should be a pre-mix fuel
with a 50:1 fuel to oil ratio. This will insure the
engine is lubricated and give the oil pump
time to bleed any air from the oil line that may
have occurred during shipping.
The oil tank capacity is 1.1 liters, 1.2qt.
Changing Transmission Oil
1. Place an oil catch pan under the unit
directly below the transmission box.
2. Remove the transmission box drain plug
located on the bottom of the transmission
box on the underside of the unit.
3. Remove the transmission box fill whole
plug locate on top of the transmission
box near the oil tank bracket on the left
hand side of the unit.
4. Allow the oil to drain completely (15-30
min).
5. Reinstall the drain plug and tighten.
Engine Oil
Your ATV uses 2 cycle oil to lubricate the engine.
The oil tank is located under the seat at the front
of the unit. Oil is drawn from this tank by an oil
injector pump when the engine is operating.
Oil Tank
Oil Level Warning Light
Torque to 7-10lbf-ft
6. Fill the transmission box with SAE 80-90
gear oil.The transmission box capacity is
300cc / 10.2oz.
7. Reinstall the fill hole plug finger tight.
8. Dispose of used oil at a proper recycling
station as required by law.
(For Yukon )
ST.
Oil Level
Warning Light
(For Viper )
ST.
TRANSMISSION OIL
Page 15
Transmission
Fill Whole Plug
Summary of Contents for EXL-50 - SERVICE
