Maintenance
Every 500 hours—Replace
the spark plug (Kohler
engine).
Ensure that the air gap between the center and side
electrodes is correct before installing the spark plug.
Use a spark plug wrench for removing and installing
the spark plug and a gapping tool or feeler gauge to
check and adjust the air gap. Install a new spark plug
if necessary.
The spark plug is RFI compliant. Equivalent alternate
brand plugs can also be used.
Type:
Champion XC12YC or equivalent
Air Gap:
0.030 inch (.76 mm)
Removing the Spark Plug–Kohler
engine
1. Disengage the PTO and ensure the parking brake
is engaged.
2. Stop the engine, remove the key, and wait for all
moving parts to stop before leaving the operating
position.
3. Disconnect the wire from the spark plug.
B
A
g027478
Figure 45
4. Clean around the spark plug to prevent dirt from
falling into the engine and potentially causing
damage.
5. Remove the spark plug and metal washer.
Checking the Spark Plug–Kohler
Engine
1. Inspect the spark plug
Note:
If you see light brown or gray on the
insulator, the engine is operating properly. A
black coating on the insulator usually means the
air cleaner is dirty.
Important:
Do Not clean the spark plug.
Always replace the spark plug when it has a
black coating, worn electrodes, an oily film,
or cracks.
B
A
g027479
Figure 46
1.
Center electrode
insulator
3.
Air gap (not to scale)
2.
Side electrode
2. Check the gap between the center and side
electrodes.
3. Set the gap to 0.030 inch (.76 mm).
Installing the Spark Plug–Kohler
Engine
1. Install the spark plug. Make sure that the air gap
is set correctly.
2. Tighten the spark plug to 18 to 22 ft-lb (25 to 29
N-m).
Figure 47
3. Push the wire onto the spark plug.
47
Summary of Contents for QSS708GEM42200
