FIELD OPERATION
FIELD OPERATION
Utility Sprayer 25' / 30' / 40' / 45'
Page 63
14.
Open the tank valve and adjust the
agitation valve to a position
determined when the application rate
was calibrated.
15.
Proceed into the field at a constant
speed. Use the same gear, engine
RPM, and ground speed determined
when the application rate was
calibrated.
16.
Operate the controls to activate the
boom sections. Monitor and adjust
pressure.
17.
When the field job is complete, turn
off the section control switches and
close the tank valve.
18.
Follow the procedure to rinse the
tank. See
19.
When the rinse is complete, stop the
tractor, set the parking brake, remove
the key, and wait for all moving parts
to stop before leaving the tractor
seat.
20.
Close the tank valve.
21.
Fold the wings into transport position.
22.
Transport the machine to its storage
location.
23.
Disconnect the machine from the
tractor.
Adjust Ground Speed
It will be necessary to establish a travel
speed and then set the flow to give the
desired application rate. Always run at the
established travel speed.
Travel speed recommendations are given in
Table 1. However, the crop or plant type,
recommendations
by
the
chemical
manufacturer, and local conditions may
affect the appropriate speed to use per
application.
Table 1: Recommended travel speeds
MPH
KPH
Cereal Crops
(Broadcast)
6 – 10
9.7 – 16
Row Crops
4 – 10
6.4 – 16
General
5 – 8
8.0 – 13
For more information on speed selection,
Always operate at a comfortable speed. Do
not operate so quickly that the machine
bounces while going through the field.
Effective results require that liquid be applied
in a consistent manner. Machine bouncing
will prevent this required consistency.
Broadcast Spraying
It is recommended that the operator makes
one pass around the field and then moves
back and forth to obtain the best results.
Using a marker system helps to prevent
skips or overlaps.
If the field has headlands, be sure to allow
sufficient space for turning.
Summary of Contents for UT3P25
