OD42 Outdoor Gas Fireplace
7
INSTALLATION
IMPORTANT MESSAGE
SAVE THESE
INSTRUCTIONS
The OD42 Gas Fireplace must be installed in
accordance with these instructions. Carefully read
all the instructions in this manual fi rst. Consult the
"authority having jurisdiction" to determine the need
for a permit prior to starting the installation. It is the
responsibility of the installer to ensure this fi replace
is installed in compliance with manufacturers
instructions and all applicable codes.
BEFORE YOU START
Safe installation and operation of this appliance
requires common sense, however, we are required
by the Canadian Safety Standards and ANSI
Standards to make you aware of the following:
GENERAL SAFETY
INFORMATION
1)
The installation must conform with local
codes or, in the absence of local codes, with
CAN/CSA-B149.1
, Natural Gas and Propane
Installation Code or
CAN/CSA-B149.2
, Propane
installation code the Natural Gas Fuel Code,
ANSI Z223.1/NFPA 54
.
2)
The appliance when installed, must be
electrically grounded in accordance with local
codes, or in the absence of local codes with the
Canadian Electrical Code CSA C22.1or with
the National Electrical Code, ANSI/NFPA 70.
3)
See general construction and assembly
instructions. The appliance should be enclosed.
4)
Inspect the burner before each use of the
appliance for blockage and any signs of
deterioration.
CHILDREN AND ADULTS SHOULD
BE ALERTED TO THE HAZARDS OF
HIGH SURFACE TEMPERATURES,
ESPECIALLY THE FIREPLACE GLASS
AND FACEPLATE, AND SHOULD STAY
AWAY TO AVOID BURNS OR CLOTHING
IGNITION.
THIS APPLIANCE SHALL BE USED ONLY
OUTDOORS IN A WELL-VENTILATED
SPACE AND SHALL NOT BE USED IN
A BUILDING, GARAGE OR ANY OTHER
ENCLOSED AREA.
INSTALLATION AND REPAIR SHOULD
BE DONE BY AN AUTHORIZED SERVICE
PERSON. THE APPLIANCE SHOULD
BE INSPECTED BEFORE USE AND
AT LEAST ANNUALLY BY A PROFES-
SIONAL SERVICE PERSON. MORE FRE-
QUENT CLEANING MAY BE REQUIRED
DUE TO EXCESSIVE LINT FROM CAR-
PETING, BEDDING MATERIAL, ETC.
IT IS IMPERATIVE THAT CONTROL
COMPARTMENTS, BURNERS AND CIR-
CULATING AIR PASSAGEWAYS OF THE
APPLIANCE BE KEPT CLEAN.
ANY GUARD OR OTHER PROTECTIVE
DEVICE REMOVED FOR SERVICING
THE APPLIANCE MUST BE REPLACED
PRIOR TO OPERATING THE APPLIANCE
WARNING: FAILURE TO INSTALL THIS
APPLIANCE CORRECTLY WILL VOID
YOUR WARRANTY AND MAY CAUSE A
SERIOUS FIRE.
CLOTHING OR OTHER FLAMMABLE
MATERIAL SHOULD NOT BE PLACED
ON OR NEAR THE APPLIANCE.
DO NOT USE THIS APPLIANCE IF ANY
PART HAS BEEN UNDER WATER. IMME-
DIATELY CALL A QUALIFIED SERVICE
TECHNICIAN TO INSPECT THE APPLI-
ANCE AND TO REPLACE ANY PART
OF THE CONTROL SYSTEM AND ANY
GAS CONTROL WHICH HAS BEEN
UNDER WATER.
YOUNG CHILDREN SHOULD BE CARE-
FULLY SUPERVISED WHEN THEY ARE
IN THE SAME AREA AS THE APPLI-
ANCE. TODDLERS, YOUNG CHILDREN
AND OTHERS MAY BE SUSCEPTIBLE
TO ACCIDENTAL CONTACT BURNS. A
PHYSICAL BARRIERS IS RECOMMEND-
ED IF THERE ARE AT RISK INDIVIDUAL
IN THE HOUSE. TO RESTRICT ACCESS
TO A FIREPLACE OR STOVE, INSTALL
AN ADJUSTABLE SAFETY GATE TO
KEEP TODDLERS, YOUNG CHILDREN
AND OTHER AT RISK INDIVIDUALS OUT
OF THE ROOM AND AWAY FROM HOT
SURFACES.
5)
To prevent injury, do not allow anyone who is
unfamiliar with the operation to use the fi replace.
6)
Wear gloves and safety glasses for protection
while doing required maintenance.
7)
Maximum gas inlet pressure = 1/2 psig.
8)
Under no circumstances should this appliance
be modifi ed. Parts that have to be removed for
servicing should be replaced prior to operating
this appliance.
9)
Installation and any repairs to this appliance
should be done by a qualifi ed service person.
A professional service person should be called
to inspect this appliance annually. Make it a
practice to have all of your gas appliances
checked annually.
10)
Under no circumstances should any solid fuels
(wood, paper, cardboard, coal, etc.) be used in
this appliance.
11)
The appliance and its individual shutoff valve
must be disconnected from the gas supply
piping system during any pressure testing of
that system at test pressures in excess of 1/2
psi (3.5kPa).
The appliance must be isolated from the gas
supply piping system by closing its individual
manual shutoff valve during any pressure testing
of the gas supply piping system at test pressures
equal to or less than 1/2 psi (3.5 kPa).
12)
The appliance area must be kept clear and
free of combustible materials, (gases and other
fl ammable vapours and liquids).
It is highly recommended to protect the
interior from moisture (rain, snow). Cover
the enclosure opening when not in use. This
fi replace is only for use with the type of gas
indicated on the rating plate. This fi replace
is not convertible for use with other gases,
unless a certifi ed kit is used.
13)
Cover
must
be removed when burner is in
operation.
14)
When not using appliance for extended periods
of time - turn off gas supply.
Emissions from burning wood or gas could
contain chemicals known to the State of
California to cause cancer, birth defects or
other reproductive harm.
Summary of Contents for OD42-N
Page 5: ...OD42 Outdoor Gas Fireplace 5 DIMENSIONS UNIT DIMENSIONS WITH 2 FACEPLATE ...
Page 6: ...6 OD42 Outdoor Gas Fireplace DIMENSIONS UNIT DIMENSIONS WITH 4 FACEPLATE ...
Page 36: ...36 OD42 Outdoor Gas Fireplace NOTES ...
Page 37: ...OD42 Outdoor Gas Fireplace 37 NOTES ...
