321144
127
15.2 Service Reference ‘T’ Models
Problem
Possible Causes
What To Do
PC TOO COLD
Total Compartment Too
Cold.
* FC fan not going.
- Check for fault code (refer to Sections 10.1.1
or 10.2.1).
- Check for mechanical obstruction.
- Check for broken wires.
- Check polarity.
- Replace fan.
* Short of gas.
- Check run percentage. If high, check
evaporator.
- Check fully flooded evaporator, check for leak.
* PC sensor inaccurate. - Check calibration of sensor ice point using
interface binary (refer to Sections 10.1.5 or
10.2.3) or refer to thermistor resistance table
(refer to Section 4.22).
PC TOO WARM
Total Compartment
Warm.
* Evaporator ice up.
- Check defrost element, check continuity.
- Check door seal/door left open.
* No refrigeration.
- Does compressor run? If no, check power
supplies. If yes, check refrigeration system.
- If running, check for live frost/fully flooded
evaporator. If not, check for leak.
* Fans not working.
- Check for fault code (refer to Sections 10.1.1
or 10.2.1).
- Is there a 12Volt supply, PC light working?
- If yes, check fan connection(s) at fan end, also
at power/control module end of the harness.
- If no, check for power/control module failure.
- Check fan is not a Y97-16 stalling on fan
speed 3.
* Power/control module
failure.
- Are lamp / interface LED’s working?
- If not, check display module connection.
- If OK, is compressor running?
- If not, replace power/control module.
* PC delivery duct
blocked.
- De-ice area behind chassis.
FC TOO COLD
Total Compartment Too
Cold.
* FC sensor location.
- Check set temperature.
- Sensor clipped and located in correct
position?
* Faulty sensor.
- Check calibration of sensor ice point using
interface binary (refer to Sections 10.1.5 or
10.2.3) or refer to thermistor resistance table
(refer to Section 4.22).
* PC fan not going.
- Check for fault code (refer to Sections 10.1.1
or 10.2.1).
- Check for mechanical obstruction.
- Check for broken wires.
- Check polarity.
- Replace fan.
Summary of Contents for 635 Active Smart
