Owner’s Manual for Flameless Heat Cart
9
General Information
Engine performance will be diminished if fuel other than
what is specified is used. See the engine manual for
more information.
Hydraulic Oil
Type: Exxon Mobil DTE-10 ISO VG 68 hydraulic oil.
Cart Towing Guidelines
NOTE:
Do not exceed 15 mph (24 km/h).
The front axle is steered by a tow bar with a pintle ring
hitch. It is equipped with a mechanical parking brake
activated by raising the tow bar to the locked position.
NOTE:
See the tow vehicle manual for coupling instruc-
tions.
Driving a vehicle with a cart in tow is vastly different than
driving the same vehicle without a cart in tow. Consider
the following:
•
It takes longer to get up to speed.
•
More room is needed to turn.
•
More distance is needed to stop.
•
The driver is responsible for keeping the vehicle
and cart in control, and for all damage caused if
control is lost.
Before towing, verify the following:
•
Coupling, tires, wheels, and lights are in working
order.
•
Wheel lug nuts are tightened to 100 ft-lbs (135.6
Nm).
•
The unit is not running.
While towing, make regular stops to verify the following:
•
Coupler is secured to the hitch and locked.
•
No damage or unusual wear to tire treads or side-
walls.
•
Cart and doors are latched and secured.
Parking Brake Use
See
. Engage the parking brake by raising the
tow bar to the locked position. The locking lever (A) holds
the tow bar in place. Do not operate the unit without the
parking brake engaged.
Lift the locking lever up and slowly lower the tow bar to
disengage the parking brake.
NOTE:
Do not attempt to move the unit with the parking
brake engaged; equipment damage may occur.
Applicable Standard
Recommendation
JIS (Japanese Industrial Standard)
No. 2
DIN (Deutsche Industrie Normen)
DIN 51601
SAE (Society of Automotive
Engineers)
Based on SAE-J-313C
No. 2-D
BS (British Standard)
Based on BS/2869-1970
Class A-1
DANGER
(000239)
Hydraulic Fluid Injection. High-pressure, high-temperature
hydraulic fluid can pierce skin and cause severe burns. Do not
check for leaks with hands. Seek immediate medical attention in case of
accident. Failure to protect body accordingly will result in death or serious
injury.
WARNING
Property or Equipment Damage. Tighten wheel lug
nuts every 30 days to factory specifications. Failure to
do so could result in death, serious injury, or property
or equipment damage.
(000364)
WARNING
Control loss. Trailer must be securely coupled to the
hitch. An incorrectly coupled trailer could result in loss
of control, death, or serious injury.
(000360)
WARNING
Crushing hazard. Verify parking brake is properly
secured and unit is on level ground. An unsecured
unit could suddenly roll or move, and could result in
death, serious injury, or equipment damage. (000352)
CAUTION
(000313)
Pinching and crushing hazard. To avoid
possible injury, keep fingers away from pivot
point when folding or unfolding trailer tongue.
Summary of Contents for MAC400HC
