Generac Power Systems MAC400HC, Owner'S Manual

Owner’s Manual for Flameless Heat Cart

3

Introduction and Safety

Towing Hazards

Battery Hazards

Always recycle batteries in accordance with local laws
and regulations. Contact your local solid waste collection
site or recycling facility to obtain information on local
recycling processes. For more information on battery
recycling, visit the Battery Council International website
at: 

http://batterycouncil.org

Service Safety

•

DO NOT perform even routine service (oil/filter
changes, cleaning, etc.) unless all electrical com-
ponents are shut down.

•

Replace all missing and hard to read decals.
Decals provide important operating instructions
and warn of dangers and hazards.

•

Wear all task-appropriate Personal Protective
Equipment (PPE) when completing  maintenance
or service tasks.

WARNING

Explosion and fire risk. Do not smoke near unit. 
Keep fire and spark away. Failure to do so could 
result in death, serious injury, or property or 
equipment damage.

(000282)

WARNING

Crushing hazard. Verify parking brake is properly 
secured and unit is on level ground. An unsecured 
unit could suddenly roll or move, and could result in 
death, serious injury, or equipment damage. (000352)

WARNING

Property or Equipment Damage. Tighten wheel lug 
nuts every 30 days to factory specifications. Failure to 
do so could result in death, serious injury, or property 
or equipment damage.

(000364)

WARNING

Control loss. Trailer must be securely coupled to the 
hitch. An incorrectly coupled trailer could result in loss 
of control, death, or serious injury.

(000360)

Personal injury. Do not operate unit during transport. 
Doing so could result in death, serious injury, or 
property damage.

(000231a)

WARNING

(000137a)

WARNING

Explosion. Batteries emit explosive gases while charging. 
Keep fire and spark away. Wear protective gear when 
working with batteries. Failure to do so could result in 
death or serious injury. 

(000162)

WARNING

Explosion. Do not dispose of batteries in a fire. Batteries 
are explosive. Electrolyte solution can cause burns and

blindness. If electrolyte contacts skin or eyes, flush with water 
and seek immediate medical attention.

(000163a)

WARNING

Risk of burn. Do not open or mutilate batteries. 
Batteries contain electrolyte solution which can 
cause burns and blindness. If electrolyte contacts
skin or eyes, flush with water and seek immediate
medical attention.

(000130)

WARNING

Accidental Start-up. Disconnect the negative battery 
cable, then the positive battery cable when working 
on unit. Failure to do so could result in death 
or serious injury.

WARNING

Environmental Hazard. Always recycle batteries at an 
official recycling center in accordance with all local 
laws and regulations. Failure to do so could result in
environmental damage, death or serious injury.

(000228)