General International AC1106, Setup And Operation Manual

ENGLISH

11

141209

Parts List

PARTS LIST

TROUBLESHOOTING

TROUBLE

POSSIBLE CAUSE

CORRECTIVE ACTION

Compressor Will Not Start

1.  Blown fuse or circuit breaker 

tripped

2. Loose electrical connections

1.  Replace or reset fuse/circuit 

breaker

2. Check wiring connections

Low Pressure

1. Restricted air filter

2. Defective check valve

3. Air leak in safety valve 

1. Replace air filter

2. Replace check valve

3.  Check valve by pulling on ring. If 

condition persists, replace valve.

Safety Valve Releasing

1. Defective Pressure Switch

1. Replace pressure switch

Oil Discharge in Air

1. Too much oil in crankcase

2. Compressor overheated

3. Restricted oil breather cap

1.  Drain crankcase and refill to prop-

er level on oil sight glass

2. Reduce air pressure regulation

3. Clean or replace oil breather cap

REF. N

O.

DESCRIPTION

QTY.

1

Screw

6

2

Exerior circlip

1

3

Fan

1

4

Back cover

1

5

Wave washer

1

6

Screw bolt

3

7

Spring washer

3

8

Lock nut

3

9

Stator

1

10

Rotor

1

11

Bearing

1

12

Seal ring

1

13

Crankcase

1

14

Oil baffle plate

1

15

Crankcase cover

1

16

Oil sight glass assembly

1

17

Screw

4

18

Breather assembly

1

19

Capacitor

2

20

Lock washer

2

21

Nut M8

2

22

Screw bolt

1

23

Crank

1

24

Connection rod

1

25

Piston pin

1

26

Interior circlip

2

27

Piston

1

28

Oil clean ring

1

29

Oil seal ring

2

30

Cylinder gasket

1

31

Cylinder

1

32

Valve plate gasket

1

33

Valve plate

2

34

Seal gasket

1

35

Valve gasket

2

REF. N

O.

DESCRIPTION

QTY.

36

Crankcase cover gasket

1

37

Right-angle connector

1

38

Cylinder cover

1

39

Flat washer

4

40

Spring washer

4

41

Screw bolt

4

42

Air filter

1

43

Exhaust pipe assembly

1

44

Non-return valve

1

45

Unloader pipe

1

46

Handle grip

1

47

Safe valve assembly

1

48

Pressure switch

1

49

Connector

1

50

Regulator assembly

1

51

Quick change connector

1

52

Pressure gauge

1

53

Pressure gauge

1

54

Lock nut

1

55

Cord and plug

1

56

Screw 

4

57

Spring washer

4

58

Tank

1

59

Plastic cover

1

60

Bearing

1

61

Drain valve

1

62

Rubber foot

4

63

Flat washer

4

64

Screw bolt

4

65

Spring washer

4

66

Nut 6

5

67

Seal washer

2

68

Fender washer 5

10

69

Fender washer 6

4