Troubleshooting
3A8108A
43
Troubleshooting
1.
Follow
page 7, before checking or repairing unit.
Problem
Cause
Solution
Engine won’t start.
Engine switch is OFF.
Turn engine switch ON.
Engine is out of gas.
Refill gas tank. Refer to Honda Engines
Owner’s Manual.
Engine oil level is low
Try to start engine. Replenish oil, if nec-
essary, see
Honda Engine Owner’s Manual.
Spark plug cable is disconnected or
damaged.
Connect spark plug cable or replace
spark plug.
Cold engine.
Use choke.
Fuel shutoff lever is OFF.
Move lever to ON position.
Oil is seeping into combustion chamber.
Remove spark plug. Pull starter 3 to 4
times. Clean or replace spark plug. Start
engine. Keep TapeLazer upright to avoid
oil seepage.
Engine rope is difficult to pull, making
engine starting hard.
Air pressure in the cylinder makes it
harder to pull-start the engine.
High engine speed at no load.
Mis-adjusted throttle setting.
Reset throttle to 3000 engine RPM at no
load.
Worn engine governor.
Replace or service engine governor.
Refer to Honda Engines Owner’s Man-
ual.
Distance not adding properly (measure
mode and speed will be inaccurate.)
Unit is not calibrated.
21.
Pavement is uneven and rear right tire is
not remaining on pavement when apply-
ing tape.
Add weight to the back of the TapeLazer.
There is an area under the spare roller
storage area for this purpose.
Remove segment(s) of application
and/or taping roller(s) to match width of
tape. See
Blade doesn’t cut tape or provides poor
cuts.
Blade guard is attached.
Remove blade guard from blade.
Blade is dull or worn.
Replace blade.
No or low air pressure.
Pressurize unit. Verify system is achiev-
ing full pressure. Check for air leaks or
damaged air lines and cylinders. See
Brake is worn.
Replace brake.
Low system pressure.
Check for leaks.
Summary of Contents for TapeLazer HP Automatic
