Appliance description (pic. 1 and 2)
a
Fixing
clamp
b
Hex
screw
c
Tension
clamp
d
Burden
hook
e
Limit switch for lifting
f
Engine
g
Switch
body
h
Controller
i
Safety
switch
j
Hook
holder
k
Cable
drum
l
Tension
weight
m
Steel
cable
n
Idler
o
Bracket
p
Limit switch for sinking
Warranty
The warranty exclusively applies to material or manufacturing
defects. The original proof of purchase including the date of
purchase must be submitted when applying XXX a claim in
the warranty period.
The warranty does not cover any unauthorised use such as
appliance overload, violent use, damage by a foreign person
or an undesirable item. The failure to follow the Operating
Instructions and assembly instructions and common wear and
tear are also excluded from the warranty.
Important basic safety instructions
Before you start working with the appliance please read
carefully the following safety regulations and Operating
Instructions. If any other person is to handle the appliance
provide him/her with the Operating Instructions. Keep the
Operating Instructions for future reference!
Package:
The appliance has been put in a package to
prevent any damage during transport. Packages are raw
materials so they can be reused or recycled.
Please read carefully the Operating Instructions and follow
them. Use these Operating Instructions to get acquainted
with the appliance, its corresponding use and safety
instructions. Keep the Instructions for future reference.
•
The cable reel can only be operated by persons who
have thoroughly read and understood these Operating
Instructions. The cable reel must not be operated by
persons not sufficiently instructed or not in a good
health state.
•
Inspect the appliance visually before each use. Do not
use the appliance if any safety device is damaged or
worn out. Never remove any safety device.
•
Use the appliance only for the purpose specified in
these Operating Instructions.
•
Be always careful when working. Watch your activity.
Proceed carefully. Do not use the cable reel if you are
not concentrated.
•
Safety in the workplace is your responsibility.
•
Never leave the appliance unattended.
•
Put the appliance to a safe place if you need to
interrupt your work.
•
Do not use the appliance when raining or in a humid or
wet environment
•
Never spray water on the cable reel or submerge it to
any liquid.
•
Do not use electric tools near flammable liquids or
gases.
•
Do not switch the appliance on if turned over or not in
the operating position.
•
Keep the appliance out of reach of other persons,
especially children and pets.
•
Do not let other persons touch the appliance or cable.
•
After you finish working with the appliance, pull the
plug out of socket and check if the appliance is not
damaged.
•
If the appliance is not used store it to a dry place
inaccessible to children.
•
The system voltage must correspond to the voltage
specified on the type label.
•
Any repairs can only be executed by an electrician.
•
Before putting the appliance into operation and after
any impact check it for any wear-out or damage and
have necessary repairs executed.
•
Never use spare parts and accessories not
recommended by the producer.
•
Use the appliance only in broad daylight or under
sufficient artificial lighting.
•
Make sure no item
causes short-circuit
on appliance
contacts.
•
Lay all cables in a manner to prevent risk of trip and to
eliminate cable damage!
•
Wear
protective
clothing suitable for the given
environment the whole time you work and take suitable
preventive measures to prevent accidents.
•
Do not use the cable for any other purpose than
specified. Do not wear the cable by its cable and do
not use the cable for pulling the plug out of socket.
Protect the cable against excessive temperatures, oil
and sharp edges.
•
Be very careful of your appliance. Keep it clean so that
working with it is fine and safe. Regularly check the
plug and cable and have them repaired by an
authorised specialist if damaged. Regularly check the
extension cables and have any damaged cable
replaced by a specialist.
•
Extension cables to be used outdoors only. For
outdoor work, use extension cables adequately marked
and approved for that purpose (within 20 m
∅
1.5 mm²,
20-50 m
∅
2.5 mm²)
•
Unplug the appliance
- before every cleaning
- after each use
•
Persons unable to operate the appliance due to their
physical, sensory or mental abilities or their
inexperience or lack of knowledge must not operate
it.
•
If the appliance, feeder cable or steel cable show any
sign of visible damage the appliance must not be put
into operation.
•
If the feeder cable of the appliance is damaged it
needs to be replaced by the producer or an
electrician.
•
Repairs of the appliance can only be executed by an
electrician. There might be significant risks as a
result of unauthorised repairs.
•
The same regulations apply for accessories
.
Güde GmbH & Co. KG does not answer for damages
caused by:
•
Appliance damage by mechanical influences and
overloading.
•
Any changes to the appliance.
•
Use for any other purpose than that described in
the Operating Instructions.
•
Unconditionally follow all safety instructions to
prevent accidents and damage.
Important safety instructions
•
The cable winch must be checked before starting work if
all components are working perfectly. In particular, check
the perfect state of the snap hooks preventing any
unintentional release of the lifting hook from slings
(ropes, rings, transportation eyes, etc.).
•
The cable reel can only be used for lifting of burdens
whose weight does not exceed the maximum load
10
