01-1481-00-00.fm
25
Safety instructions
1.5.14 Electrical system
1.5.15 Vacuum sweeping system
Danger
•
Work on the electrical system may be done only in accordance with electrical engineering
standards by a specialist trained for this work.
•
Welding work on the vehicle may be done only by authorised Hako dealers. Welding work on the
vehicle leads to damage to the control electronics and can impair driving safety.
•
Danger of explosion due to smoking, fire or open light! Especially when being charged, but also in
the normal use of batteries, batteries emit explosive gases! Avoid smoking, fire, sparks or open
light in the vicinity of batteries!
•
Danger of explosion due to sparks! Never place tools or other electrically conductive objects on
the battery! Sparks that can ignite escaping gases arise if the poles are short-circuited.
•
Danger of explosion due to frozen battery or too low acid level! With a frozen battery or if the acid
level is too low, do not attempt to start with a jumper cable, the battery can burst or explode.
•
Danger of burns due to battery acid! The special safety and accident prevention regulations must
be complied with when handling the battery. Batteries contain sulphuric acid. Only store battery
acid in the closed original container, and keep out of the reach of children.
•
Risk of fire! When carrying out work on the fuses, switch off the electrical system to disconnect the
consumers from the power supply. Use only original fuses. If stronger fuses are used, the
electrical system can be destroyed and there can be fires.
Attention
•
Always disconnect the battery when working on the electrical system or when performing welding
work.
•
Always observe the correct order when connecting and disconnecting the battery!
•
Disconnecting the battery: First the minus pole and then the plus pole!
•
Connecting the battery: First the plus pole and then the minus pole!
•
After every maintenance task involving disconnecting the battery, make sure that the clamps are
firmly seated on the terminals on re-connection.
•
Disconnect the battery from the vehicle electrical circuits before recharging the battery. Do not
disconnect the battery while the engine is running. Observe the precautions in the usage instruc-
tions and the product description for the battery. Do not use a battery charging device to start the
engine.
•
Note the operating voltage of the vehicle!
•
Check the vehicle's electrical equipment at regular intervals. Defects such as loose connections or
scorched cables must be removed immediately.
•
Before replacing a light bulb, switch off the ignition to disconnect the consumers from the power
supply. Only ever replace light bulbs with new ones with the same version and rating (amperage).
Do not touch the glass bulb of the halogen light with your bare fingers.
Environmental danger
•
Used batteries with the recycling symbol contain reusable commodities. In accordance with the
symbol showing the crossed-out garbage bin, these batteries must not be disposed of in the
domestic waste. Return and recycling have to be arranged with the authorised Hako dealer as
required in § 6 and § 8 of the German battery law (BattG)!
Danger
•
It is not permitted to stand underneath the dirt hopper if it is not secured. Always fit the safety strut
whenever working underneath the dirt hopper. There is a danger to life!
•
Special caution is required in the area of the front and rear-mounted equipment and attachments.
There is a danger to life!
Summary of Contents for Citymaster 2200
Page 35: ...02 1481 00 00 fm 35 Operation Fig 3 34 31 29 32 33 34 35 36 37 30...
Page 39: ...02 1481 00 00 fm 39 Operation Fig 5 73 74 71 72 72 71 74 75 76 82 83 84 77 78 79 81...
Page 43: ...02 1481 00 00 fm 43 Operation Fig 7 114 116 117 118 119 120 115 113 112...
Page 236: ...236 05 1481 00 00 fm Maintenance and servicing...
