32
32
POSSIBLE CAUSE
:
■
Insufficient Air Flow
Through Burn Pot
■
Lack Of Fuel, Poor Fuel
Quality, Obstruction In
Feed System
■
Temperature sensor
(RTD)
SOLUTION
:
■
Check burn pot for ash build-up or obstructions. Follow
Care and Maintenance
instructions for ash build-up. Check the fan to make sure it is working properly, and
air intake is not blocked. Follow
Care and Maintenance
instructions if dirty. Check
auger motor to confirm operation, and make sure there is no blockage in the auger
tube. Once all the above steps have been done, start the pellet grill, set temperature
to 300
°
F (148
°
F) and ignite the pellet grill. Check the fire is bright and vibrant.
■
Check hopper to check that fuel level is sufficient and refill if low. Should be
poor quality of wood pellets, or the length of the pellets too long, this may cause
an obstruction in the hopper and auger. Remove pellets and follow Care and
Maintenance instructions.
■
Check status of temperature probe. Follow
Care and Maintenance
instructions if
cover with creosote. Contact Consumer Service for a replacement part if damaged.
PELLET GRILL WILL NOT ACHIEVE OR MAINTAIN TEMPERATURE
POSSIBLE CAUSE
:
■
Grease build-up
■
Quality of wood pellets
■
Blocked burn pot
■
Insufficient air intake
for fan
SOLUTION
:
■
Follow
Care and Maintenance
instructions.
■
Remove moist wood pellets from hopper. Follow
Care and Maintenance
instructions
to clean out. Replace with dry wood pellets.
■
Remove moist wood pellets from burn pot and hopper and clear the auger tube by
select Clean Out mode.
■
Check the fan and make sure it is working properly and air intake is not blocked.
Follow
Care and Maintenance
instructions if dirty.
PELLET GRILL PRODUCES EXCESS OR DISCOLORED SMOKE
POSSIBLE CAUSE
:
■
Cooking temperature
■
Grease build-up on
cooking components
SOLUTION
:
■
Attempt cooking greasy food at a lower temperature. Grease does have a lower flash
point. Keep the temperature under 350°F (176°C).
■
Follow
Care and Maintenance
instructions.
FREQUENT FLARE-UPS
Halo Consumer Service
Toll-free: (833) 572-1688
Summary of Contents for PRIME300 HS-1005-ANA
