Hamilton Beach Commercial MIXSTATION HMD1000, Operation Manual

4

To the Operator

Your safety and the safety of others is very important. We 

have provided many important safety messages in this 

manual and on your appliance. Always read and obey 

all safety messages. Read thoroughly and understand 

the instructions within this manual before operating or 

performing any maintenance on the appliance. Before 

allowing operation of this appliance, operator must be 

trained and approved by management staff.
The MixStation™ you have purchased is intended for use 

in commercial and professional environments requiring 

trained operators. Such environments may include, but 

not be limited to, restaurants, bars, fast-food outlets, 

hospitals, catering businesses, etc.
The MixStation™ is designed to mix drinks made from 

yogurt, frozen custard, granita, hard or soft ice cream. 

MixStation™ is also ideal for mixing candy, fruit, and nuts 

into the shake-type drinks. Use of this appliance outside 

of this scope may result in fire, electric shock, severe 

personal injury, or equipment damage. 

Basic Recipe follows:
•  1/4 cup (60 mL) cookies or candies, or other mix-ins
•  Four rounded scoops or approximately 12 ounces  

(355 mL) of hard ice cream

•  1/3 cup (80 mL) milk
Power Switch (located on back of MixStation™) is 

provided with an integral circuit breaker to automatically 

turn off unit in over-current conditions that may occur 

due to excessive loads to the motor. When this occurs, 

allow MixStation™ to cool down for 30 minutes and then 

turn unit ON. If unit does not operate, contact Technical 

Services for further direction.
This Operation Manual must be read and fully 

understood before operating or performing any 

maintenance on your appliance.

MixStation™ Safety

Unpacking

Carefully remove MixStation™ from packaging and take 

out all boxes or packets containing attachments or specific 

items. Check that all of the parts have been delivered, that 

the MixStation™ operates as intended, and that nothing 

has been damaged in transit. Contact Technical Services 

to remedy any findings.

Installation

Position MixStation™ on a sturdy level surface and in 

an open, well-lighted environment that provides easy 

access to all controls, front and side. We recommend 

that you position MixStation™ so that the working height 

of the Agitator and controls are appropriate for intended 

operator(s).

Noise Level

The equivalent continuous sound level when equipment  

is operating at maximum speed on no-load is less  

than 90 dB(A).

Connection

Observe all electrical governing codes and ordinances. 

A 120V AC-only, 60 Hz, 15-amp, fused electrical supply 

is required. (A time-delay fuse is recommended.) It is 

recommended that a separate circuit serving only this 

appliance be provided.

Maintenance

Check Agitator daily for wear or damage. 

Standard Conformity

MixStation™ is in compliance with: 
•  UL 763 and CSA C22.2 No. 195 Motor-Operated 

Commercial Food Preparing Machines

•  ANSI NSF Standard 8