R
R
Turbo Vac TV60R
Set-Up and Operation
SAFETY WARNING!
Wear approved eye protection and safety
gear during set-up and operation of the
Turbo Vac.
TV60RE
1.
Fill the tank with gasoline. (Refer to
engine manual for gasoline specifics.)
2.
Attach the unit to the tow vehicle. Be
sure that the Turbo Vac is level with the
ground. (Refer to the Adjustments
section for information on leveling.)
4.
Pull choke and turn key to start position
and release as soon as the engine
starts.
DO NOT TURN THE STARTER
OVER FOR MORE THAN 10 SEC-
ONDS.
5.
Once the engine is running, gradually
move the choke lever to the off posi-
tion, and allow the engine to warm up.
(When restarting a warm engine, it
should not be necessary to use the
choke lever.)
SAFETY WARNING!
Never remove the fuel tank cap or add
gasoline when the engine is running or
while it is hot.
6.
The engine will automatically throttle
up to operating speed when the blower
and broom are engaged.
SAFETY WARNING!
Periodically clean material away from
engine to lessen the possibility of fire.
TV60RH
1.
Before using the
TV60RH
for the first
time, install the battery cable onto the
tractor battery to supply power to the
unit’s valve and RF receiver. Connect
the black wire of the cable to the
negative terminal and the red wire
(with fuse) to the positive terminal of
the battery. When using more than one
tractor, other power cords may be or-
dered (p/n 93
5017
).
2.
Attach the unit to a tractor with a PTO.
Be sure that the Turbo Vac is level with
the ground. (Refer to Adjustments
section.)
3.
Slide the hydraulic gear pump onto the
PTO shaft of the tractor.
4.
Fasten the torque bar or chain to the
tractor to prevent the pump from
rotating.
5.
Make certain that the case drain hose
is on top of the pump and in a vertical
position when attached to the tractor.
6.
Plug quick connector on battery cable
to the quick connector located on the
tongue of the
TV60RH
.
7.
Engage tractor PTO and set to 540
RPM.
13
Summary of Contents for TURBO VAC 60R
