Hatco TOAST-QWIK TQ-300, Installation And Operating Manual

IMPORTANT SAFETY INSTRUCTIONS

5

Form No. TQCEM-1002

CAUTIONS

The toasting of coated products such as garlic bread, cheese
sandwiches and sweet rolls is NOT recommended. Residue 
will reduce toaster performance and could possibly ignite
inside the toaster.

When setting up the unit for operation, make sure power
to the unit is off and the toaster is at room temperature.
Failure to do so could result in personal injury.

Some exterior surfaces on the unit will get hot. Use caution
when touching these areas to avoid injury.

CAUTIONS

Do not locate the toaster in an area subject to excessive
temperatures or grease from grills, fryers, etc. Excessive
temperatures could cause damage to the unit. Do not place
toaster in an area that restricts air flow around the motor
compartment. Do not place toaster in direct discharge path 
of air conditioning vent or makeup air vent.

Abrasive cleaners could scratch the finish of your
Toast-Qwik toaster.

Failure to lubricate the rear motor bearing as recommended
will reduce the operating life of the motor and possibly void
the warranty.

WARNINGS

Allow a minimum of 3 cm (1") along the sides. Allow 
a clearance of 31 cm (12") along the front and rear
discharge to ensure proper operation and safety.

This appliance is not of jet-proof construction. Do not use 
jet-clean-spray to clean this appliance.

Plug toaster into an electrical outlet of the correct voltage, 
size and plug configuration. If the plug and receptacle 
do not match, contact a qualified electrician to determine 
the proper voltage and size and install the proper
electrical outlet.

If service is required on this unit, contact your Authorized
Hatco Service Agent, or contact the Hatco Service
Department at 800-558-0607 or 414-671-6350; 
fax 800-690-2966 or International fax 414-671-3976.

This product has no “user” serviceable parts. To avoid
damage to the unit or injury to personnel, use only
Authorized Hatco Service Agents and Genuine Hatco Parts
when service is required.

Genuine Hatco Replacement Parts are specified to operate
safely in the environments in which they are used. Some
aftermarket or generic replacement parts do not have 
the characteristics that will allow them to operate safely 
in Hatco equipment. It is essential to use Hatco Replacement
Parts when repairing Hatco equipment. Failure to use Hatco
Replacement Parts may subject operators of the equipment 
to hazardous electrical voltage, resulting in electrical 
shock or burn.

MODEL DESCRIPTIONS

ALL MODELS 

All Toast-Qwik Electric Conveyor Toasters are fast, dependable 
and versatile, toasting up to 300 or 700 slices of bread product 
per hour. The front or rear discharge lets the operator place 
Toast-Qwik where it is most convenient. Every Toast-Qwik includes
a toast collector pan, toast feed ramp, removable crumb tray 
and factory attached 183 cm (6') cord and plug. An optional
stacking unit allows you to put TQ-300’s or TQ-700’s on top 
of one another for greater capacity and variety of product. 

TQ-300

The TQ-300 model allows for toasting of bread products up 
to 3 cm (1-1/4") thick and 25 cm (9-5/8") wide. Capacity 
is up to 300 slices per hour for bread or bun products.

TQ-300BA

The TQ-300BA model allows for quick single sided toasting 
of sliced bagels. Most bagels can be completed in as little 
as 45 seconds. Capacity is up to 300 bagel halves per hour. 
Toasts cut side 

facing down

.

TQ-700

The TQ-700 model allows for toasting of bread products 
up to 3 cm (1-1/4") thick and 25 cm (9-5/8") wide. Capacity 
is up to 700 slices per hour for bread or bun products.

TQ-700H

The TQ-700H has a 8 cm (3") wide opening allowing for toasting
of thicker bread products. Separate controls allow the operator 
to set top and bottom toast colors separately.

TQ-700H-S

The TQ-700H-S has a 8 cm (3") wide opening allowing for toasting 
of thicker bread products and an accelerated conveyor system
allowing faster toasting to meet periods of high demand.

TQ-700HBA

The TQ-700HBA is designed to provide the flexibility 
and performance to toast sliced bagels perfectly in as little 
as 30 seconds. Capacity is more than 700 bagel halves per hour.
Toasts cut side 

facing up

.