22
2 1 0 0 B A L E B U S T E R
O P E R A T I N G I N S T R U C T I O N S
NOTE:
Operate bale conveyor to rotate the bale in direction indicated by arrow on the front shield.
Reverse direction only if the bale is lodged or hesitates to turn.
CAUTION:
Serious injury could result if machine is allowed to tip.
3.2.4 Normal shut-down procedure
WARNING:
For your safety and the safety of others, you must use the following normal shut-down
procedure before leaving the tractor controls unattended for any reason, including servicing, cleaning,
or inspecting the 2100 BALEBUSTER. A variation of the following procedure may be used if so
instructed within this manual or your tractor manual or if an extreme emergency requires it.
To shutdown the machine, perform the following steps:
1.
Shut hydraulic drive off for chain conveyor.
2.
Disengage PTO
3.
Lower machine to ground level.
4.
Place transmission in park or set park brake
5.
Shut Off engine and remove key.
6.
Wait for all movement to stop.
3.2.5 Unhitching the 2100 BALEBUSTER from a tractor
To unhitch the 2100 BALEBUSTER from a tractor, perform the following steps:
1.
Run the 2100 BALEBUSTER until it is empty.
2.
Shut-down the2100 BALEBUSTER as described above, keeping the 2100 BALEBUSTER high enough
to allow adjustment and lowering of the jackstands.
3.
Remove the jackstand and pins, and turn jackstands 90° so that the machine can be supported by the
jackstands. Reinstall the jackstands and pins on their brackets.
4.
Lower machine until the 2100 BALEBUSTER rests on both jackstands.
5.
Disconnect the hydraulic hoses from the tractor.
NOTE:
Operating tractor PTO at 1000 RPM allows machine to do a better job of chopping forage
and also keeps a minimum of twine build-up on the rotor. Twine build-up should be kept to a
minimum to reduce fire hazard.
Summary of Contents for 2100 BALEBUSTER
