Page 1
AIR CLEANERS / FILTERS
Litho U.S.A.
507477-01
4/2016
Supersedes 4/2015
PUREAIR AIR PURIFICATION SYSTEM
PHOTOCATALYTIC OXIDATION (PCO)
TECHNOLOGY
INSTALLATION INSTRUCTIONS FOR PUREAIR AIR PURIFICATION SYSTEM
MODELS PCO3-14-16, PCO3-16-16 AND PCO3-20-16
THIS MANUAL MUST BE LEFT WITH THE
HOMEOWNER FOR FUTURE REFERENCE
Shipping & Packing List
Assembled PureAir air purification system which
includes:
Cabinet (1)
UVA Lampholder / PCO cartridge (secure to interior of
cabinet) (1)
UVA lamp in box (secure to interior of cabinet) (1)
Healthy Climate
®
Carbon Clean 16 Filter (located in
interior of cabinet) (1)
UVA lamp socket with 4-pin male connector assembly
attached to light ballast electrical connector (1)
Literature Bag includes power cord (120VAC)*,
installation instruction, UVA Lamp Socket brass finger
nuts (2), UVA Lampholder / PCO cartridge wing nuts
(2) and warranty.
*230VAC power cord available separately (part number
91X44).
Shipping Damage
Check equipment for shipping damage. If damage is
found, immediately contact last carrier.
General Information
The PureAir air purification system uses photo-catalytic
oxidation (PCO) technology to reduce levels of airborne
volatile organic compounds, cooking odors, common
household odors, airborne dust particles, mold spores and
pollen. The PureAir air purification system is available in
three models (PCO3-14-16, PCO3-16-16 and
PCO3-20-16). Each unit may be connected to either
120VAC or 230VAC power supply.
Lab tests confirm a 50% reduction in
total volatile
organic compounds
(TVOC) within the first 24 hours of
initial operation of the PureAir air purification system. It
may take up to 48 hours after initial system start-up to
reduce the airborne chemicals that have built up in a home
over a long period of time.
For peak performance, unit should be installed in homes
with TVOC levels that are less than 1000 micro-gram /
cubic meter. Home source removal and ventilation may be
required to lower total volatile organic compounds to this
level.
The Healthy Climate
®
Carbon Clean 16 Filter combines
industry-leading MERV 16 filtration and carbon-coated
fiber matrix.
Access Panel
Opening for
Power Cord
UVA lamp
Viewer
Healthy Climate
®
Carbon Clean 16
Filter
Cabinet
Rear Mounting bracket for UVA
Lampholder / PCO Cartridge
UVA Lamp
UVA Lampholder / PCO
Cartridge
Hinged
Control Panel
UVA lamp ballast with electrical
connector (not shown)
NOTE:
Lampholder assembly shipped
installed to ballast electrical
connector.
Lampholder Wiring
Figure 1. Parts Identification