Hearthstone Quality Home Heating Products, Inc
CHAMPLAIN DV Model 8301
I
NSTALLER
’
S
I
NFORMATION
C
ODES
Adhere to
all
local codes
or, in their absence,
obtain the latest edition of THE NATIONAL FUEL
GAS CODE ANSI Z223.1 (NFPA 54) or CAN/CGA
B149 Installation Code from:
AMERICAN NATIONAL STANDARDS INSTITUTE, INC.
1430 BROADWAY
NEW YORK, NY 10018
www.ansi.org
OR
NATIONAL FIRE PROTECTION ASSOCIATION, INC.
BATTERY MARCH PARK
QUINCY, MA 02269
www.nfpa.org
The appliance, when installed with a blower, must
be electrically connected and grounded in
accordance with local codes or, in the absence of
local codes, with the current NFPA 70-National
Electrical Code or CSA C22.1-Canadian Electric
Code.
A manufactured home (or mobile) OEM installation
must conform to the Manufactured Home
Construction and Safety Standard, Title 24 CFR,
Part 3280 (U.S.) or Standard for Manufactured
Home Installation, ANSI/NCBCS A225.1 or Standard
for Gas Equipped Recreational Vehicles and mobile
Housing, CSA Z240.4.CAN/SCA Z240 MH
(Canada).
(Installer l’appareil selon les codes ou
règlements locaux, ou, en l’absence de tels
règlements, selon les Codes d’installation
CAN/CGA-B149.)
For installations from 610-1370 meters (2000-4500
ft.) the orifice sizes (DMS) for natural and propane
gas are 32 and 52 respectively. See data plate for
additional information. For high altitude installations
consult the local gas distributor or the authority
having jurisdiction for proper rating methods. If the
installer must convert the unit to adjust for varying
altitudes, the information sticker must be filled out by
the installer and adhered to the appliance at the
same time of conversion.
(Cet appareil est equipè
pour des altitudes compries entre 0 et 2000 pieds
(0-610 m) seulement.)
U
NPACKING AND
I
NSPECTION
Unpack and Inspect for Damage
Hearthstone packages the Champlain to withstand
normal shipment without damage. However,
damage can still occur during transit, so take care to
inspect for damage when unpacking and installing
the unit. If you detect any damage, or a missing part,
immediately contact your dealer.
Do not install or put into service a damaged
or incomplete heater.
The unit should appear square and level, with the
sheet metal parts smooth and free of bends or
dents. Enameled cast iron should be free of chips or
cracks. If you find visible or concealed damage,
contact your dealer.
P
ACKING
L
IST
1-Champlain DV Gas-fired Heater containing:
6-Decorative Fiber Logs
1-Pan Burner
1-Owner’s Manual and Warranty
1-Bag Charcoal Embers
1-Bag Platinum Bright Embers
2-Decorative Caps
1-Accessory box containing:
1-Top Grille
1-Thermostat with Thermostat Wire
2-Extension control Knobs
1-LP Conversion kit
F
IBER
L
OG
S
AFETY
I
NFORMATION
The decorative fiber logs supplied with the
Champlain are located in the firebox. Always use
great care when handling the decorative fiber logs,
as they are fragile and subject to damage and
breakage. If the decorative fiber logs supplied with
the Champlain are damaged, they must be replaced.
Contact your local Hearthstone dealer for
replacement parts. Do not replace fiber logs, or the
embers, with any materials not approved by
Hearthstone.
F
IREBOX
A
CCESS
To open the firebox:
1. Remove the two upper front screws (located in
the grill of the front) that hold the cast façade
onto the unit.
(These screws ship on the unit
for transit purposes only and are removed
during installation.)
2. Open the valve access door by pulling the ash
lip out off the magnet and down. Allow the door
to swing down completely.
Page 8 of 30
