Hearthstone Quality Home Heating Products, Inc.
CHAMPLAIN Model 8303
24
Restrictor Plate Adjustment
Loosen the screw and position the restrictor plate in
the desired location. Tighten the screw to lock in
place.
Figure 22 - Restrictor Fully Open Detail (baffle
removed for clarity)
Figure 23 - Restrictor Adjuster Arm Detail
Routine Maintenance
and Care
Your Champlain requires minimal routine
maintenance and care. Ensure the unit is cool
and off when cleaning, or servicing.
WARNING:
DO NOT SUBSTITUTE MATERIALS.
For replacement parts, or for information about parts
or service, contact your local Hearthstone dealer.
Any safety screen or guard removed for
servicing an appliance must be replaced prior to
operating the appliance. Tout écran ou
protecteur retiré pour permettre l’entretien de
l’appareil doit être remis en place avant de
mettre l’appareil en marche.
Cleaning
WARNING: DO NOT CLEAN THE UNIT WHEN HOT.
The unit should receive regular cleaning on, under,
and around the stove to prevent the buildup of dust
and lint. The exterior surfaces of the unit can be
cleaned using soap, water, and a soft cloth. Do not
use abrasive or chemical cleaners and take care not
to scratch the glass or enamel finish (if so equipped)
when cleaning the unit. The use of chemical wax
based cleaners or polishes are not recommended
due to the potential for discoloration of the castings,
or enamel when the residue of the cleaners or
polishes is exposed to heat. Excessive buildup of
dust, spider webs, or room air contamination may
cause odors when the stove is hot.
Monthly (or as needed):
Glass Cleaning
As fuel gas may contain some impurities; it will be
necessary to clean the inside of the glass
occasionally. Do not use abrasive cleaners.
Scratching the glass will weaken the integrity of the
glass.
Do not clean the glass when hot!
Allow the
glass to cool and apply a mild window cleaning fluid.
Special gas appliance window cleaner is available
from your local Hearthstone dealer.
WARNING: DO NOT OPERATE THIS APPLIANCE
WITH THE GLASS PANEL REMOVED, CRACKED,
OR BROKEN. DO NOT SUBJECT THE GLASS OR
ITS FRAME TO ABUSE, SUCH AS STRIKING OR
BENDING. REPLACEMENT OF THE GLASS
PANEL SHOULD BE DONE BY A LICENSED OR
QUALIFIED SERVICE PERSON. NE PAS UTILISER
L’APPAREIL SI LE PANNEAU FRONTAL EN
VERRE N’EST PAS EN PLACE, EST CRAQUÉ OU
BRISÉ.
CONFIEZ
LE
REMPLACEMENT
DU
PANNEAU À UN TECHNICIEN AGRÉÉ.
NOTE:
If the venting system is disassembled for any
reason, re-install per the instructions provided in the
venting section of this manual.
Annually:
Clean Firebox, Pilot, & Burner Assembly
The firebox requires periodic cleaning to prevent the
accumulation of dust, lint, and other debris. To clean
the firebox, set the switch to the “OFF” position, and
turn off the gas supply to the valve. When the unit is
cool, remove the front panel and glass (see page 8
for Firebox Access instructions) and carefully
