Model 290
The electric fryer requires two switching contactors: a primary and a
heat contactor. The primary contactor energizes (contacts close)
any time the POWER/PUMP switch is in the POWER position, and
the temperature of the shortening is below 420° F ( 215° C). The
high limit cuts power at the primary contactor if the temperature of
the shortening is above 420° F ( 215° C). The primary contactor
supplies power to one side of the heat contactor.
The heat contactor is controlled by the computer controller. When
the controller calls for heat, the heat contactor applies power to one
side of the heating elements. When the heat contactor and primary
contactor are energized (contacts closed) the electric heating
elements heat the shortening.
The photo shows a mercury heat contactor, but CE countries
will have an electromechanical heat contactor.
Checkout
1. Remove electrical power supplied to the fryer.
To avoid electrical shock or property damage, move the
power switch to OFF and disconnect main circuit
breaker, or unplug cord at wall receptacle.
2. Remove the control panel.
3. Label and remove wires from contactors and perform a check
on both contactors as follows:
Test Points
Results
From 23 to 29
open circuit
From 24 to 28
open circuit
From 25 to 27
open circuit
From 30 to 34
open circuit
From 31 to 35
open circuit
From 32 to 36
open circuit
From 33 to 37
ohm reading 1700
From 22 to 26
ohm reading 415
2-9. CONTACTORS
Primary
Heat
1103
2-8
33
37
30 31 32
34
35
36
Summary of Contents for OFE-290
