3.4.3
Battery Charger (CB)
The battery charger is located inside the battery compartment, underneath the operator seat. To facilitate
charging and charge control, an additional Socket and a LED display is installed, easily accessible by lifting the
recovery tank. At the start of the charging cycle, the charger indicates the selected charging algorithm by the
LED flashing.
A Proper Charging cycle follows the below phases order.
Charging cycle
Phase
LED
Description
A
Green
Flashes, confirms Charge Curve Setting
B
Red
First charging phase
C
Yellow
Second charging phase
D
Green
Charged battery
Check if the charger is properly set according to the installed batteries.
Charger Set up
To set up the charger, follow the instructions:
Remove the charger from the machine.
Set-up the internal dipswitches according to the following table
The dipswitches are divided in two couples.
The higher couple are the dipswitches 1 and 2, the low
couple are the dipswitches 3 and 4.
The dipswitches 1, 2 4 are enabled
The dipswitch 3 is disabled.
The following table shows how to setup the dip-
switches.
46
Summary of Contents for 108538
