Periodic Service
10-18
of pressure within the cooling system.
5. Adding the LLC
1) Add only water if the mixture reduces in
amount by evaporation.
2) If there is a mixture leak, add the LLC of
the same manufacturer and type in the
same mixture percentage.
* Never add any long-life coolant of
different manufacturer.(Different brands
may have different additive components,
and the engine may fail to perform as
specified.)
6. When the LLC is mixed, do not employ
any radiator cleaning agent. The LLC
contains anticorrosive agent. If mixed with
the cleaning agent, sludge may build up,
adversely affecting the engine parts.
7. The vehicle’s genuine long-life coolant has
a service life of 2 years. Be sure to
change the coolant every 2 years.
NOTE:
The above data represent industry
standards that necessitate a minimum
glycol content in the concentrated
antifreeze.
When the coolant level drops due to
evaporation, add water only to keep the
antifreeze mixing ratio less than 50%. In
case of leakage, add antifreeze and water
in the specified mixing ratio before filling
into the radiator.
■
Replacing Radiator Hose (Water pipes)
Replace the hoses and clamps.
(See “Checking Radiator Hose and Clamp” in
“EVERY 200 HOURS” in “PERIODIC
SERVICE” section.)
■
Replacing Fuel Hose
Consult your local HUANSONG Dealer for
This service.
■
Replacing Brake Master Cylinder (Inner
parts)
Consult your local dealer for this service.
■
Replacing Front Brake Seal
Consult your local dealer for this service.
■
Replacing Rear Brake Cylinder Seal
Consult your local dealer for this service.
■
Replacing Intake Air Line
Consult your local dealer for this service.
EVERY 4 YEARS
■
Replacing Brake Hose
Consult your local Dealer for this service.
■
Replacing Mini Fuses
The Mini fuses are intended to protect the
electrical cabling. If any of them have blown
out, be sure to pinpoint the cause.
◆
Replacing procedure
1) Disconnect the negative cable of the
battery.
2) Open the Mini fuse box cover.
3) Pull out the Mini fuse.
4) Insert a new Mini fuse into the box.
5) Close the Mini fuse box cover.
6) Connect the negative battery cable.
Summary of Contents for 550UTV/HS
