Periodic Service
6-10
①
Battery
1. To slow charge the battery, connect the
battery positive terminal to the charger
positive terminal and the negative to the
negative. then recharge in the standard
fashion.
2. A boost charge is only for emergencies it will
partially charge the battery as early as
possible.
3. When exchanging an old battery for a new
one use battery of equal specification shown
in table 1.
Battery type
Volts
12V32Ah
12
◆
Direction for storage
1. When storing the vehicle for a long period,
remove the battery from level vehicle, store in
a dry place out of direct sunlight.
2. The battery will self discharge while it is
stored, recharge it once every three months in
hot seasons and once every six months in
cold seasons.
■
Adjusting toe-in
Proper toe-in
0 to12 mm (0 to 0.47 in)
1. Park vehicle on flat place.
2. Turn steering wheel so front wheels are in the
straight ahead position.
3. Lock the park brake and stop the engine.
4. Measure distance between tire beads at rear of
tire at hub height.
5. Front distance should be shorter than rear
distance, if not adjust tie rod length.
①
Wheel-to-wheel distance at front
②
FRONT
◆
Adjusting procedures
1. Loosen the lock nut and turn the tie rod to
adjust the rod length until the proper toe-in
measurement is obtained.
2. Retighten the lock nut.
IMPORTANT
Keep equal length of the left and right tie-rod.
