PERIODIC SERVICE 10-16
“TROUBLESHOOTING”
section
in
this
manual, and then start the engine again.
■
Checking Intake Air Line
1. Check to see if the hoses and hose clamps
are tight and not damaged.
2. If hoses and clamps are found to be worn or
damaged, replace or repair them at once.
①
Hose
②
Hose clamp
EVERY 300 HOURS
■
Checking Tires
1. Check to see if tires are not damaged.
2. If the tires are cracked, bulged, or cut, or they
are worn out, replace or repair them at once.
◆
Tire Tread Depth
Always replace the tires when the tread depth is
worn to minimum allowable.
①
3mm(0.12in)
EVERY 400 HOURS
■
Changing Transmission Fluid
CAUTION
To avoid personal injury:
Park the vehicle on a flat surface, raise the
cargo bed, and apply the parking brake.
Allow engine to cool down sufficiently, oil
can be hot and can cause severe burns.
1. Park the vehicle on a flat surface, raise the
cargo bed, and apply the parking brake.
2. To drain the used oil, remove the drain plug at
the bottom of the transmission case and drain
the oil completely into the oil pan.
3. After draining, reinstall the drain plug.
4. After running the engine for a few minutes,
stop the engine and check the oil level again;
add oil to prescribed level.
①
Drain plug
IMPORTANT:
Do not operate the vehicle immediately after
changing the transmission fluid.
Run the engine at medium speed for a few
minutes
to
prevent
damage
to
the
transmission.
■
Changing Front and Rear Axle Case Oil
1. Park the vehicle on a firm, flat and level
surface.
2. To drain the used oil, remove the drain the oil
Summary of Contents for STRIKE 1000
