9
system should be installed close
to kitchen/cooking area
prepare at least 2.7 x 5.2m space
for the system
(0.5m side, 0.7m front clearance for
maintenance & daily usage)
prepare a firm, flat surface clear of
obstructions - do not place on soft
or unstable ground
e.g. flat dry ground, tile, concrete
do not place system on shipping
pallets or other weak raised
surfaces
place system within reach of a
water supply
2.5m
4.2m
0.5m
0.5m
0.5m
0.7m
preparation for gas pipe installation
The system can be connected to a stove/appliance up to 18m away (18m gas tubing provided).
Plan a suitable route for the gas pipe to ensure optimum gas flow and prevent damage to the pipe -
follow detailed instructions for gas pipe installation on page 26, after assembling system.
up to 18m
There should be
NO
U-shaped bends along the pipe, where
water will collect and block gas flow.
For protection from damage and accidents, you can pass
the pipe underground or elevate it on nearby structures.
Use a rigid pipe to protect the tubing and prevent bends.
It is important to install the pipes at a slight angle from the
system - the lowest point(s) will be used to drain water
collected in the tubes.
Summary of Contents for HBG 4.0
