Hoover BH90200, User Manual

2

 DANGER:

 RISK OF FIRE OR EXPLOSION. DO NOT SPRAY FLAMMABLE 

LIQUIDS SUCH AS GASOLINE. LOOK FOR THIS SYMBOL REFERENCE ON THE CONTAINER.

• Do not operate the product in explosive atmospheres, such as in the presence of flammable 

liquids, gases or dust� Power tools create sparks which may ignite the dust or fumes�

• Do not smoke while using the sprayer, or spray where spark or flame is present� 

• To reduce the risk of fire or explosion use a liquid with a flash point higher than 140°F (60°C)�

• Electric shock hazard� Never spray toward electrical outlets�

• Do not use bleach or hydrogen peroxide�

• Do not use alcohol based chemicals�

• Do not use vinegar or pine oil based solutions�

• Do not use powders or abrasive chemicals� 

• Do not use caustic (alkali) or self-heating liquids in this sprayer�

• Do not point the sprayer nozzle in the direction of people or pets�

• Risk of injection� Do not discharge directly against skin�

WARNING:

 RISK OF FIRE, PROPERTY DAMAGE, AND INJURY. NEVER EXPOSE YOUR 

BATTERY PACK OR CHARGER TO WATER, MOISTURE, OR FLUIDS, INCLUDING BUT NOT LIMITED 

TO CORROSIVE OR CONDUCTIVE FLUIDS, OR ALLOW FLUIDS TO FLOW INSIDE THESE ITEMS.

Corrosive or conductive fluids, such as salt water, chlorine, certain industrial chemicals, and 

bleach or bleach containing products, etc�, can cause a short circuit in the battery pack� If your 

battery pack is exposed to a corrosive or conductive fluid, do not attempt to use or charge the 

battery pack and immediately perform the following steps:

• Wear appropriate personal protective equipment, including eye protection and rubber gloves� 

• Place your exposed battery pack in a large bucket, such as a 5 gallon or similar bucket, and 

fill the bucket with regular tap water� Do not place more than two packs in the bucket� 

• Locate the bucket outdoors in an area inaccessible to children and pets and away from all 

buildings, garages/sheds, structures, vehicles, and combustible/flammable materials� 

• Leave the battery pack(s) in the bucket filled with tap water and call Customer Service at  

1 (800) 406-2005 for additional instructions on the proper disposal of the exposed battery 

pack(s)�

WARNING:

BEFORE FILLING THE TANK, ALWAYS REMOVE THE BATTERY PACK. 

WIPE UP ANY SPILLS BEFORE INSERTING THE BATTERY PACK. FOLLOWING THIS RULE WILL 

REDUCE THE RISK OF ELECTRIC SHOCK AND CORROSIVE LIQUIDS ENTERING THE BATTERY 

PACK, WHICH CAN CAUSE BATTERY PACK FAILURE INCLUDING SHORT CIRCUIT RESULTING 

IN SMOKE, FIRE, AND/OR SERIOUS PERSONAL INJURY.

WARNING:

DO NOT ALLOW CONDUCTIVE OR CORROSIVE FLUIDS TO GET INSIDE 

THE BATTERY PACK. IF CONDUCTIVE OR CORROSIVE FLUIDS ARE SPILLED ON THE BATTERY, 

REFER TO THE INSTRUCTIONS IN YOUR BATTERY OPERATOR’S MANUAL.

• Avoid accidental starting� Ensure the switch is in the off position before inserting battery 

pack� Inserting the battery pack into products that have the switch on invites accidents�

• Disconnect the battery from the unit before draining, cleaning, or storing the sprayer� Such 

preventive safety measures reduce the risk of accidental starting�

• Recharge only with the HOOVER charger� A charger that is suitable for one type of battery 

pack may create a risk of injury and fire when used with another battery pack� See page 2 

for charger compatibility�

• Use products only with specifically designated battery packs� Use of any other battery 

packs may create a risk of injury and fire� See page 2 for battery compatibility�

• When battery pack is not in use, keep it away from other metal objects, like paper clips, 

coins, keys, nails, screws or other small metal objects, that can make a connection from one 

terminal to another� Shorting the battery terminals together may cause burns or a fire�

• Exercise care in handling batteries in order not to short the battery with conducting 

materials such as rings, bracelets, and keys� The battery or conductor may overheat and 

cause burns�

• Under abusive conditions, liquid may be ejected from the battery; avoid contact� If contact 

accidentally occurs, flush with water� If liquid contacts eyes, additionally seek medical help� 

Liquid ejected from battery may cause irritation or burns�

• Under extreme usage or temperature conditions, battery leakage may occur� If liquid comes 

in contact with your skin, wash immediately with soap and water� If liquid gets into your 

eyes, flush them with clean water for at least 10 minutes, then seek immediate medical 

attention� Following this rule will reduce the risk of serious personal injury�

• Do not use a battery pack or appliance that is damaged or modified� Damaged or modified 

batteries may exhibit unpredictable behavior resulting in fire, explosion or risk of injury�

• Do not open or modify the battery pack� Released electrolyte is corrosive and may cause 

damage to the eyes or skin� It may be toxic if swallowed�

• Do not expose a battery pack or appliance to fire or excessive temperatures� Exposure to fire 

or temperature above 265°F/130°C may cause explosion�

• Do not dispose of the battery(ies) in a fire� The cell may explode� Check with local codes for 

possible special disposal instructions�

• Do not crush, drop or damage battery pack� Do not use a battery pack or charger that has 

been dropped or received a sharp blow� A damaged battery is subject to explosion� Properly 

dispose of a dropped or damaged battery immediately�

• Batteries can explode in the presence of a source of ignition, such as a pilot light� To reduce 

the risk of serious personal injury, never use any cordless product in the presence of open 

flame� An exploded battery can propel debris and chemicals� If exposed, flush with water 

immediately� 

• Do not charge battery tool in a damp or wet location� Following this rule will reduce the risk 

of electric shock� 

• Follow all charging instructions and do not charge the battery pack or appliance outside of 

the temperature range specified in the instructions� Charging improperly or at temperatures 

outside of the specified range may damage the battery and increase the risk of fire�

• Have this product serviced by a qualified repair person using only identical replacement 

parts� This will ensure that the safety of the power tool is maintained� 

• When servicing the product, use only identical replacement parts� Follow instructions in the 

Maintenance section of this manual� Use of unauthorized parts or failure to follow 

Maintenance instructions may create a risk of shock or injury�

• Do not modify or attempt to repair the appliance (or the battery pack) except as indicated in 

the instructions for use and care�

Every ONEPWR

™

 battery works 

with every ONEPWR

™

 product.

Parts and Accessories:

Battery:

Model #

Charger

BH05000

2�0 Ah

BH15020

Dual Bay Charger

BH05200

3�0 Ah

BH15030

0�5A Compact Charger

440014514

3�0 Ah MAX

BH25030

1�5A Compact Charge

440014513

4�0 Ah

BH15240

4�0 Ah MAX

BH25040

6�0 Ah

BH15260

CAUTION

– TO REDUCE THE RISK OF DAMAGE:

• Store appropriately indoors in a dry place� Do not expose machine to freezing temperatures�

• Stay alert, watch what you are doing and use common sense when operating this product� 

Do not use while you are tired or under the influence of drugs, alcohol or medication� A 

moment of inattention while operating this product may result in serious personal injury�

• Keep the sprayer and its handle dry, clean and free from oil and grease� Always use a clean 

cloth when cleaning� Never use brake fluids, gasoline, petroleum based products, or any 

strong solvents to clean your tool� Following this rule will reduce the risk of loss of control 

and deterioration of the enclosure plastic�

• Use this product in accordance with these instructions and in the manner intended, taking 

into account the working conditions and the work to be performed� Use of the product for 

operations different from those intended could result in a hazardous situation�

• Do not let familiarity gained from frequent use of tools allow you to become complacent and 

ignore tool safety principles� A careless action can cause severe injury within a fraction of  

a second�

• Do not pour hot or boiling liquids into the tank� These can weaken or damage the tubes or tank�

• Avoid spraying on windy days� Spray can be accidentally blown onto objects that should not 

be sprayed�

• Do not leave residue or spray material in the tank after using the sprayer� Clean after each use�

• Spray area must be well ventilated�

• Maintain this product� Thoroughly inspect both the inside and outside of the sprayer and 

examine the components before each use� Check for cracked and deteriorated tanks, leaks, 

clogged nozzles, and missing or damaged parts� If damaged, have the product repaired 

before use� Many accidents are caused by poorly maintained products�

CAUTION:

• To reduce the risk of electric shock, do not touch the nozzle during use.
• Keep all body parts out of the spray pattern.

BATTERY DISPOSAL WARNING

 - RISK OF EXPLOSION OR 

EXPOSURE TO TOXIC MATERIAL (INCLUDE LITHIUM ION BATTERY RECYCLE GRAPHIC WITH 

PHONE NUMBER 1-800-822-8837

IMPORTANT SAFETY INSTRUCTIONS 

SAVE THESE INSTRUCTIONS (CONT’D)