Hunter Marine 2004 41 Owner'S Manual Download

Page: 103 / 141

12V.D.C. SYSTEM TROUBLESHOOTING GUIDE

TO POWER D.C. PANEL: STD. BATTERY CHARGER MODEL TURN ON HOUSE BATTERY SELECTOR SWITCH TO

STD. BATTERY CHARGER MODEL

TURN (HOUSE) BATTERY SW ITCH TO

THIS IS TO POW ER PANEL

THE "ON" POSITION, THEN TURN ON "D.C. MAIN" BREAKER ON MAIN DIST. PANEL.

FOR CHARGING

, SEE

IF NO POWER TO PANEL:

CHECK

"RESET"

HOUSE) BATTERY SW ITCH PANEL

ON (HOUSE) BATTERY SW ITCH PANEL

PAGE 63A-2

AND/OR BATT. CONNECTIONS IF NECESSARY.

TO POWER D.C. PANEL:

OPTIONAL INVERTER MODEL

, TURN ON "D.C. MAIN" BREAKER ON PANEL, IT IS

NOT

THIS IS TO POW ER PANEL

NECESSARY TO TURN ON THE HOUSE BATTERY SW ITCH TO THE "ON" POSITION

FOR CHARGING,

SEE

TO SUPPLY POW ER TO D.C. PANEL

PAGE 63A-2

IF NO POWER TO PANEL:

CHECK THE 50amp RESET

BREAKER

AND/OR THE 300 amp IN LINE

FUSES AT THE HOUSE BATT OR BATT. CONNECTIONS IF NECESSARY.

COMPONENT

SYMPTOM

POSSIBLE SOLUTION/S

D.C. MAIN

NO POW ER TO PANEL

SEE "TO POWER PANEL" ABOVE
BATTERY/S CHARGED?

PANEL LIGHTS

PANEL WON'T ILLUMINATE

SEE "TO POW ER TO PANEL" ABOVE
BATTERY TERMINALS CLEAN?
SEEK QUALIFIED PERSONELL

CABIN LIGHTS

W ON'T ILLUMINATE

SEE "TO POWER PANEL" ABOVE
BULB/S NEED REPLACING?

COURTESY LIGHTS

W ON'T ILLUMINATE

SEE "TO POWER PANEL" ABOVE

(AT CRTSY. LIGHTS
MAIN SALON)

BULBS/S NEED REPLACING?

COURTESY LIGHTS

W ON'T ILLUMINATE

SEE "TO POWER PANEL" ABOVE

ENGINE BOX COMP.

PLUNGER SW ITCH STUCK?

COCKPIT CONSOLE

IS SWITCH @ CONSOLE "ON"?

TANK INDICATOR

TANK LEVEL GAUGES DON'T ILLUMINATE

SEE "TO POWER PANEL" ABOVE

TANK LEVEL DISPLAYED IS INCORRECT

TANK SENDING UNIT NEEDS CLEANING

W ATER PRESSURE

NO POW ER

SEE "TO POWER PANEL" ABOVE

CYCLES ON/OFF EXCESSIVELY

FAUCETS OFF? LEAK IN SYSTEM SEE
PAGEC 57B,C FOR SYSTEM LAYOUT

SHOW ER SUMP

WON'T PUMP WHEN SUMP BOX FILLED

SEE "TO POWER PANEL" ABOVE

(PUMP W ON,T QUIT RUNNING)

IS FLOAT SW ITCH STUCK?

PUMP MAKES NOISE, DOESN'T PUMP

DEBRIS IN PUMP IMPELLER?

PUMP RUNS BUT DOESN'T PUMP

DISCHARGE HOSE CLOGGED?
SEACOCK DISCHARGE VALVE CLOSED?

MACERATOR

RUNS BUT DOESN'T DISCHARGE

IS DISCHARGE SEACOCK OPEN?
IS WASTE DECK FITTING SECURE, IS
IT PULLING AIR THRU? IF SO REPLACE
0- RING ON CAP.
IS TANK VENT (HULL FITTING) CLOGGED?
SEE PAGE 60A-1,A-2 FOR LOCATIONS

PUMP MAKES NOISE, DOESN'T PUMP

LODGED DEBRIS,

TURN OFF POWER

PUMP, INSERT SCREWDRIVER INTO
PUMP ARMATURE AT END OF PUMP AND
TURN TO DISLODGE DEBRIS

STEREO

W ON'T TURN ON

SEE "TO POWER PANEL" ABOVE
IS STEREO UNIT ON?

STEREO TURNS ON, NO SOUND

ARE VOLUME CONTROLS TURNED DOW N?

VCP W ON'T PLAY

SEE VIDEO PLAYER OWNERS MANUAL

ENTERTAINMENT

W ON'T TURN ON

SEE "TO POWER PANEL" ABOVE

SYSTEM

ARE TV / DVD UNITS ON?

TV TURNS ON, NO SOUND

ARE VOLUME CONTROLS TURNED DOW N
TURNED DOW N?

REFRIGERATION

W ON'T GET COLD

SEE "TO POWER PANEL" ABOVE. IS THERMOSTATS
TURNED ON? IS RAW W ATER

INTAKE

VALVE CLOSED?

UNIT KEEPS TURNING OFF

IS SEACOCK

DISCHARGE

VALVE CLOSED? IS FILTER

CLEAN? IS THRU HULL CLOGGED? SEEK QUALIFIED PERSONELL

BILGE PUMP

W ON'T OPERATE AUTO OR MANUAL

BATTERY LEVEL O.K.? SEE VOLT METER
CHECK BILGE RESET ON STRT.BATT. SEL.
SWITCH PANEL INSIDE STBD AFT GULLWING LOCKER
BATTERY CONNECTIONS GOOD?

PUMP MAKES NOISE, DOESN'T PUMP

DEBRIS IN PUMP IMPELLER?

PUMP RUNS BUT DOESN'T DISCHARGE

DISCHARGE HOSE CLOGGED?

NOTE: COMPONENT/S FAILURE COULD ALSO BE THE RESULT OF A POOR "GROUND" CONNECTION. SEE PAGE 64A
FOR BUSSBAR LOCATION. DUE TO VIBRATION, WEATHER
CONDITIONS, ECT. OCCASIONAL INSPECTION, CLEANING AND TIGHTENING OF THESE TERMINALS (BY QUALIFIED
PERSONELL) MAY BE NECESSARY.

PAGE 63A-8