Troubleshooting Guide
■
PROBLEM: The vehicle does not run disconnect charger from bike
before operation
PROBLEM CAUSE: The battery may low on power.
After each use, or once a month minimum, charge the battery for 8-12 hours. Do not leave the
battery on the charger for more than 16 hours.
POSSIBLE CAUSE: Thermal fuse has tripped.
The vehicle is equipped with a self-resetting fuse. When the vehicle is overloaded or operated
incorrectly; the self-resetting fuse will be cut off for 5-20seconds before becoming operational
again. The self-resetting fuse is under the seat (Refer to the picture.)
To avoid the fuse cutting off the power,
follow these guidelines:
DO NOT overload the vehicle, Maximum weight
allowed :30kg
DO NOT tow anything behind the vehicle.
DO NOT drive up steep slopes.
DO NOT drive into fixed objects, which may cause
the wheels to spin, causing the motor to overheat.
DO NOT drive in very hot weather, components
may overheat.
DO NOT tamper with the electric system, Doing
so may create a short circuit, causing the fuse to
trip.
POSSIBLE CAUSE: Wheel nuts are loose.
If the nuts are not tight, the wheels will not engage the forward gears. Tighten the nut with the nut wrench.
POSSIBLE CAUSE: Battery connector or wires are loose.
Make Sure the battery connectors are firmly plugged in to each other.
POSSIBLE CAUSE: Battery is dead.
Have you properly maintained the battery according to the directions? Is the battery old? Your battery
may need to be replaced.
POSSIBLE CAUSE: Electric system is damaged.
Water may have corroded the system, or loose dirt, gravel or sand might have jammed the switch.
POSSIBLE CAUSE: Motor is damaged.
The motor needs professional repair.
■
PROBLEM: The battery will not recharge.
POSSIBLE CAUSE: Battery connector or adapter connector is loose.
Make sure the battery connector and adapter connector are firmly plugged together.
POSSIBLE CAUSE: Charger is not plugged in.
Make sure the charger is plugged into the wall outlet and the power flow to the outlet is on.
POSSIBLE CAUSE: Charger is not working.
Is the charger warm while charging? If not, the charger may be broken and may need to be replaced.
FOR CUSTOMER SERVICE ENQUIRIES & SPARE PARTS
PLEASE CONTACT
HUNTER PRODUCTS TOLL FREE 1800 224 094
OR VISIT WWW.ELECTRICRIDEON.COM.AU
-14-
