Husqvarna S427, Operator'S Manual

- 7 -

•  On logs that are not square, place the 

longest portion of the log closest to the 
beam and the most square end against 
the splitter wedge.

•  Do not attempt to stabilize logs with legs or 

feet while operating. Moving parts can cut 
off or crush body parts.

•  Split logs end to end in the direction of, not 

against, the grain.

•  Keep fingers and hands away from cracks 

in logs while splitting. These can quickly 
close and pinch or crush body parts.

•  ALWAYS maintain unit in safe operating 

condition. A damaged or worn out muffler 
can cause fire or explosion. 

•  If your log splitter is equipped with an 

internal-combustion engine and intended 
for use near any unimproved forest, brush, 
or grass covered land, the engine exhaust 
should be equipped with a spark arrestor. 
Comply with applicable local, state, and 
federal codes. Have appropriate fire-
fighting equipment available. 

Personal Protection

•  Wear adequate safety shoes and 

protective gloves.

•  DO NOT wear loose clothing or jewelry 

and tie back hair that may get caught in 
moving parts.

•  Protect eyes, face and head from objects 

that may be thrown from unit. Wear 
appropriate hearing protection. Always 
wear safety goggles or safety glasses with 
side shields when operating.

Safe Fueling

•  Never use the machine indoors or in 

spaces lacking proper ventilation. The 
exhaust fumes contain carbon monoxide, 
an odorless and poisonous lethal gas.

•  Use only an approved gasoline container 

with an appropriately sized dispensing 
spout.

•  NEVER store the machine or fuel container 

where there is an open flame, spark, or 
pilot light such as on a water heater or 
other appliance.

  WARNING!  Gasoline is extremely 

flammable and the vapors are explosive.  
To avoid personal injury or property 
damage use extreme care in handling 
gasoline.

•  Extinguish all cigarettes, cigars, pipes, 

and other sources of ignition.

•  ALWAYS allow engine to cool before 

servicing.

•  NEVER fill fuel tank when engine is running 

or hot from operation.

•  NEVER fill or drain fuel tank indoors.
•  Replace fuel cap securely and clean up 

spilled fuel.

•  Never fill fuel containers inside a vehicle or 

on a truck or trailer bed with a plastic liner. 
Always place containers on the ground 
away from your vehicle before filling.

•  Keep the nozzle in contact with the rim of 

the fuel tank or container opening at all 
times until fueling is complete. Do not use 
a nozzle lock-open device.

•  If fuel is spilled on clothing, change 

clothing immediately.

•  Towing and Transport

•  Do not move the unit up or down a hill 

by hand. Use a tow vehicle with suitable 
braking system.

•  Use extra care when towing unit. DO NOT 

exceed 45 mph (72.4 kph).

•  ALWAYS stop engine, lock beam in 

horizontal position and close fuel shut-off 
valve when transporting unit.

•  Check local, state and federal laws before 

towing. Any modifications required to meet 
these laws are the responsibility of the 
purchaser.

•  Safety chains MUST be attached to vehicle 

when towing unit.

•  Disconnect unit from tow vehicle before 

using.

Maintenance and Storage

•  Clean debris and chaff from engine, 

cylinder head fins, blower housing rotating 
screen, and muffler areas. If the engine 
is equipped with a spark arrester muffler, 
clean and inspect it regularly (follow 
manufacturer’s service instructions).
Replace, if damaged. 

•  Never store the equipment with fuel in 

the tank inside a building where fumes 
might reach an open flame or spark. Allow 
the engine to cool before storing in any 
enclosure.

•  If the fuel tank has to be drained for 

storage perform this task outdoors.