OPERATING PROCEDURES
36
1. Make sure the parking brake is applied.
2. On units without a monotrol pedal, put the autoshift
control lever in the
N
(Neutral) position.
NOTE:
The engine can also be started while completely
depressing the inching/brake pedal.
3. Turn the key to
START
to engage the starter. If the out-
side temperature is 7
°
C (45
°
F) or below, crank the engine
two revolutions to prime the fuel system. Turn the key to
the
OFF
position. Push the
HEAT
button and hold it for
20--25 seconds, then engage the starter again for 10 sec-
onds.
CAUTION
Do not engage the starter for more than 30 seconds
at a time. If the engine does not start, turn the key
switch to OFF. Wait 60 seconds before engaging the
starter again.
Use only approved starting aids. Use of non--ap-
proved starting aids can result in engine damage and
void engine warranty.
4. If the engine does not start after four attempts, get help
from authorized service personnel.
5. When the engine is running, check the gauges and in-
dicator lights for the correct operation. See the Instru-
ments And Controls section for a description of the cor-
rect operation.
Starting Procedures, LPG Engine
1. If the lift truck uses LPG fuel, open the fuel valve on the
LPG tank.
WARNING
LPG is very flammable. An odor of LPG fuel can indi-
cate a leak in the fuel system. DO NOT start the en-
gine until the fuel leak is repaired.
2. Make sure the parking brake is applied or push on the
inching/brake pedal.
3. If equipped, put the direction control lever for the trans-
mission in the
NEUTRAL (N)
position.
4. Turn the key to the
START
position to engage the start-
er.
Property of American Airlines
Summary of Contents for CHALLENGER H165XL
