Section 1 Compressor Introduction
7
Compressor Safety
AIR COMPRESSOR SAFETY PRECAUTIONS
Safety is basically common sense. While there are standard safety rules, each situation has its
own peculiarities that cannot always be covered by rules. Through experience and common
sense, you are in the best position to ensure your safety. Lack of attention to safety can result in
accidents, personal injury, reduction of efficiency and worst of all, loss of life. Watch for safety
hazards. Correct them promptly. Use the following safety precautions as a general guide to safe
operation:
WARNING
All units are shipped with a detailed Operators and Parts Manual. This Manual contains vital
information for the safe use and effective operation of this unit. Carefully read the Operators
Manual before starting the unit. Failure to adhere to the instructions could result in SERIOUS
BODILY INJURY or PROPERTY DAMAGE.
Make sure all protective covers and guards are in place, and that the canopy / doors are
closed during operation.
Be very cautious in using this machine in flammable gas risk areas. Use in these areas may
require additional safety equipment such as gas detectors, exhaust spark arrestors and shut-
off valves, depending on local regulations of the level of risk involved.
Relieve pressure from the entire system before attempting to service the compressor or
removing any compressor parts.
Do not attempt to service any part while machine is operating.
Ensure adequate ventilation when releasing discharge air into a confined space.
For proper airflow, maintain a minimum of 8" of clearance on each end of the compressor. If
installing the compressor with a hydraulic aftercooler, keep 10" minimum between the
compressor and aftercooler, and maintain 8" on each end of the compressor-cooler
combination.
WARNING
Check the compressor sump oil level only when the compressor is not operating and system
is completely relieved of pressure. Open service valve to ensure relief of system air pressure
when performing maintenance on compressor air/oil system.
FAILURE TO COMPLY WITH THIS WARNING MAY CAUSE DAMAGE TO PROPERTY AND
SERIOUS BODILY HARM.
Do not operate the compressor at pressure or speed in excess of its rating as indicated in
“Compressor Specifications”.
