Operating & Maintenance Manual
Operating Instructions
26
Book: 23012958 (2-16-07) Rev. A
Before Towing
Ensure that the tires, wheels and running gear are in good condition and secure.
Towing
Do not tow this unit in excess of 20 mph (32km/hr). Use a tow vehicle whose towing capacity
is greater than the gross weight of this unit.
Setting Up (All Units)
Place the unit in an open, well-ventilated area. Position as level as possible. The design of
these units permits a maximum 15 degree sidewise limit on out-of-level operation.
When the unit is to be operated out-of-level, it is important: (1) to keep the engine crankcase
oil level near the high level mark (with the unit level), and (2) to have the compressor oil level
gauge show no more than mid-scale (with the unit running at full load). Do not overfill either
the engine crankcase or the compressor lubricating oil system.
Chock wheels.
WARNING
!
Do not connect the air discharge on this unit onto a common header with
any other unit of any description, or any other source of compressed air,
without first making sure a check-valve is used between the header and
the unit. If this unit is connected in parallel with another unit of higher
discharge pressure and capacity, a safety hazard could occur in a back-
flow condition.
WARNING
!
Unrestricted air flow from a hose will result in a whipping motion of the
hose which can cause serious injury or death. A safety device must be
attached to the hose at the source of supply to reduce pressure in case
of hose failure or other sudden pressure release. Reference: OSHA
regulation 29 CFR Section 1926.302 (b).
Summary of Contents for CSAXHP1070WCAT
