Operating Instructions
Operating & Maintenance Manual
Book: 23012958 (2-16-07) Rev. A
29
NOTE: This machine will not allow engine starting if the fuel level is below
the minimum fuel shut off level.
WARNING
!
This machine produces loud noise with doors open. Extended exposure
to loud noise can cause hearing loss. Wear hearing protection when
doors or valve(s) are open.
•
Close the side doors to maintain a cooling air path and to avoid recirculation of hot
air. This will maximize the life of the engine and compressor and protect the hearing
of surrounding personnel.
•
Make sure no one is IN or ON the compressor unit.
Starting
NOTICE
This unit is equipped with a battery disconnect switch which removes
power from the machine controller for long term storage. The switch is
located on the side of the engine near the battery.
This switch must be turned ON to provide power to the control panel for
starting this unit.
Close the air service valve to isolate the compressor from the compressed air tool until the
engine is warmed up.
1. Turn the keyswitch to the “ON” position (first position). All diagnostic lamps and
the LED display will light for two (2) seconds. All lamps should then go off and
ALTERNATOR NOT CHARGING and LOW ENGINE OIL PRESSURE lamps
will flash.
2. In freezing weather (below 32°F/0°C), flip HEATERS switch “ON” and wait sixty
(60 seconds). This applies heat to the control system components for easier
starting. Leave this switch “ON” while operating at these temperatures.
3. When the keyswitch is turned to “START” the engine starter will be engaged.
Do not operate the engine starter motor for more than ten (10) seconds
without allowing at least one minute cooling time between start attempts.
Extended engine starter engagement will result in starter drop-out and generate a
starter engagement time fault.
Summary of Contents for CSAXHP1070WCAT
