CHAPTER 8. MAINTENANCE
65
7. AIR-CLEANER
a.
The air-cleaner,1, is held on the engine with the
rubber band. Untie this band and draw out the
intake hose of radiator net and pick up the air-
cleaner by hand.
b.
Pinch the vacuum valve,2, to eject the dust
accumulated inside. When the dust is wet, wipe it
off with dry cloth.
c. Draw the element,3, out of the air-cleaner.
d.
Dust it off by patting lightly while holding it with the
other hand.
e.
When the element does not become clean only by
patting, blow dust off the element with compressed
air. Apply compressed air from inside to outside of
the element.
f.
When the element does not become sufficiently
clean only by blowing, dip it in neutral detergent
solution for about 30 minutes and then rinse it
in fresh water. Then dry it in the atmospheric
temperature.
g.
After cleaning install the element in reverse order of
disassembly.
IMPORTANT:
・
Never hit the element against a hard object like a
concrete wall.
・
An element which has already been washed five times
or is damaged should be replaced with a new one.
・
Never attempt to start the engine without the air-
cleaner element. Such operation will cause engine
trouble.
・
Never fail to insert the intake hose to radiator net.
8. FUEL
STRAINER
The fuel strainer,1, is located at middle lower on the left
side of the front mower. Check the strainer for accumulated
dust or water in the bottom of the strainer cup.
a.
When dust or water is found accumulated in the
bottom, turn the fuel cock lever,2, by 180 degrees
towards the bolt to stop fuel flowing.
b.
Remove the ring nut,3, to remove the strainer cup
and element.
c.
Wash the inside of the strainer cup and element in
diesel fuel.
DANGER:
・
Smoking is prohibited when the fuel
strainer is being cleaned or inspected.
・
Keep away sparks and open flames from
the strainer.
・
Spilled fuel should be wiped away
immediately.
(1) Air-cleaner
FIG. 95
Rubber band
Rubber band
Intake hose
Intake hose
1
(2) Vacuum valve (3) Element
FIG. 96
2
3
(1) Fuel strainer
FIG. 97
1
Summary of Contents for SBC550FH
