CHAPTER 8. MAINTENANCE
75
23. ENGINE OIL FILTER
IMPORTANT:
・
The engine oil filter should be replaced after the initial
50 hours of operation and then after every 300 hours
of operation.
・
It is recommended to ask your dealer to replace
the engine oil filter, because this operation requires
a special tool. But when there is no alternative but
to replace the filter by yourself, observe following
instructions.
The engine oil filter,1, is located on the left-hand wall of
the cylinder block.
a. Drain engine oil completely following the instructions
of "22. ENGINE OIL REPLACEMENT."
b. Place some rags under the engine oil filter to
receive dripping oil when the filter is replaced.
c.
Loosen the filter using a filter spanner and remove it.
d. Install a new filter with the O-ring lubricated with
fresh engine oil. Screw in the filter until its packing
comes into contact with the sealing surface of the
engine and then tighten it by a 2/3 turn with the filter
spanner.
e. P o u r o i l i n r e f e r r i n g t o " 2 3 . E N G I N E O I L
REPLACEMENT."
24. TRANSMISSION OIL REPLACEMENT
IMPORTANT:
・
The transmission oil should be replaced after the
initial 50 hours of operation and then after every 200
hours of operation.
・
It is recommended to ask your dealer to replace the
transmission oil, because this operation also requires
replacement of the hydraulic oil filter and washing or
replacement of the suction filter.
・
But when there is no alternative but to replace the filter
by yourself, observe the following instructions.
The transmission oil drain is located under the center of
transmission case.
a. Place a tray under the drain plug, (1), (2).
b. Remove the drain plug, (1), (2) and let the oil drain out.
c. Wrap the seal tape and reinstall the drain plug, (1),
(2) and tighten it securely.
d.
Pour fresh transmission oil through the oil filler on
top of the transmission case until the level reaches
the upper limit on the level gauge (oil level check
window) in referring to "3. TRANSMISSION OIL
LEVEL".
FIG. 119
(1) Engine oil filter
FIG. 120
1
(1) Drain
plug
Summary of Contents for SBC550FH
