CHAPTER 8. MAINTENANCE
77
Hydraulic oil filter should be replaced with cartridge.
27. REAR AXLE OIL REPLACEMENT
IMPORTANT:
・
The rear axle oil should be replaced after the initial 50
hours of operation and after 300 hours of operation.
The rear axle drain is located on the bottom of the right
and left gear cases.
a. Place a tray under the drain plug,1.
b. Remove the drain plug using a spanner or wrench.
c. Let all oil drain out from both the gear cases.
d.
Wrap the threads of the drain plug with sealing tape
and screw it back in securely.
IMPORTANT: Before re-installing the drain plug, wrap
the threads of the plug with sealing tape.
If not, oil may leaks through the plug.
e.
Pour fresh gear oil through the oil filler on the top
of the right-hand rear axle in referring to "5. REAR
AXLE OIL LEVEL".
Oil
Gear oil SAE 80
Capacity 2.5 litres (0.5 lmp, gal. )
28. AIR-INTAKE BOX
IMPORTANT:
・
Air - intake box clogged with dust or dirt causes
overheating of the engine due to deteriorated cooling
efficiency of the radiator. The air - intake screen should
be checked for clogging everyday before operation.
・
When mowing dead grass or operating under
extremely dusty conditions, check the air - intake
screen several times a day to avoid clogging.
・
Open the engine hood and clean the radiator net using
a piece of cloth or the like.
Remove the knob bolt,11 and rotate the stay,12 to
outside to remove the air intake box,10.
FIG. 124
1
2
3
(1) Drain plug
(2) Gear case
(3) Rear
wheel
FIG. 125
10
12
11
9
(9) Radiator net
(10) Knob bolt
(11) Air intake box
(12) Stay
Summary of Contents for SBC550FH
