Section 13: Exterior
126
E-Z Lube or Super-Lube Axle (If So Equipped)
The E-Z lube or Super-lube feature on your axles provides the ability for the bearings to be
periodically lubricated without removing the hubs from the axle. This feature consists of
axle spindles that have been specially drilled and fitted with grease zerks in their ends. When
grease is pumped into the zerk, it is channeled to the inner bearing and then flows back to the
outer bearing and eventually back out the grease cap hole. If you have further questions,
consult with your dealer.
NOTE:
The convenient lubrication provisions of the E-Z lube or
Super-lube feature must not replace periodic inspection and mainte-
nance of the bearings. Use a hand-operated grease gun; improper
use of a commercial grease gun may damage the seals.
Exterior Roof & Sidewall Vents
Inspect the roof vents (including sealants) for cracks and keep them clean. Inspect the
refrigerator and holding tank vents for blockages from bird nests, spider webs, leaves, etc.
All exterior access doors and vents need to be kept clean and free of obstructions (i.e., insect
nests, mud daubers, etc.) while the appliances are in use.
Sealants
Sealants perform a very important function and should be inspected closely and regularly
maintained. We incorporate many different types of sealants, including butyl/putty, black
butyl-encapsulated foam, silicone (clear and colored), roof sealant and foam. In general,
sealants do not have “set” lifetimes. Varying environmental factors affect the pliability and
adhesiveness of sealants.
You or your dealer must:
Inspect all sealants, a minimum of every six months. Make sure to check the roof
and all four sides of the recreation vehicle including al moldings, doors, vents and
exterior attachments. A quick walk around the recreation vehicle before leaving may
help prevent potential problems during trips and vacations.
Have the sealant replaced if you notice any cracks, peeling, voids, gaps, breaks,
looseness or any sign of physical deterioration. Reseal at least one time each year as
preventative maintenance.
Always use the same type of sealant that was removed. Your dealer recreation vehicle
service or parts manager can help you obtain the correct sealant(s).
The sealants may become damaged due to road vibration, ultraviolet exposure, air pollution,
freezing temperatures and exposure to other elements. If deteriorated, repair immediately
to prevent damage.
Failure to properly maintain or reseal your recreation vehicle may result in
serious water damage to the roof and other parts of the recreation vehicle. This
damage is not covered by the
Towable Limited Warranty.
Table of Contents
Maintenance Record
Summary of Contents for JAY SPORT 2018
