Section 3-2 - Routine Maintenance
Service Schedules - Machines with SD and SF Engines
Introduction
3-2-2
3-2-2
9803/3750-05 (3-20-00)
Introduction
A badly maintained machine is a danger to the operator
and the people working around him. Make sure that the
regular maintenance and lubrication jobs listed in the
service schedules are done to keep the machine in a safe
and efficient working condition.
!M
WARNING
Maintenance must be done only by suitably qualified
and competent persons. Before doing any
maintenance make sure the machine is safe. It should
be correctly parked on firm level ground.
To prevent anyone starting the engine, remove the
starter key. Disconnect the battery and block the
wheels when you are working beneath the machine.
If you do not take these precautions you could be
killed or injured.
9-3-1-1
Apart from the daily jobs, the schedules are based on
machine running hours. Keep a regular check on the
hourmeter readings to correctly gauge service intervals.
Do not use a machine which is due for a service. Make
sure any defects found during the regular maintenance
checks are rectified immediately.
Fuel System
Important: B20 Biodiesel must only be used in engines
built after January 2007 only.
If Biodiesel fuel is used there are additional service
procedures which must be carried out to prevent engine
damage. Failure to adhere to these additional procedures
may invalidate the warranty.
For these additional procedures see
How to Use the Service Schedules
In the example shown,
A
shows all service requirements to
be carried out every 10 hours and
B
shows the
requirements to be carried out every 500 hours.
Important: Services should be carried out at either the
hourly interval or calendar interval, whichever occurs first.
Refer to
Fig 1.
Calendar Equivalents
Every 10 Hours = Daily
Every 50 Hours = Weekly
Every 500 Hours = Six Months
Every 1000 Hours = Yearly
Every 2000 Hours = 2 Years
Every 6000 Hours = 6 Years
Summary of Contents for 535-125 Hi Viz
